CLUB CAR CATALOG - Vintage Golf Cart PartsImportant Notice This PDF catalog represents the products...

Parts CatalogPhone: (360) 385-4868

Fax: (360) 582-1272

Address: 160 Harrison Road #7Sequim, WA 98382

Office Hours: Monday - Friday 8 am � 4 pm

Important NoticeThis PDF catalog represents the products that have been added as of yesterday. Since products are added

regularly you may not see what you are looking for even though we have it. On parts you don't see it would bea good idea to either check back in on our site or call in to see if we have what you are looking for.

Table of ContentsCLUB CAR...........................................................................................................................................................1

ACCESSORIES........................................................................................................................................1BATTERIES & CHARGERS......................................................................................................................3BEARINGS & SEALS..............................................................................................................................10BELTS.....................................................................................................................................................18BODY, TRIM & SEATS...........................................................................................................................19BRAKES..................................................................................................................................................20BRUSHES & SPRINGS..........................................................................................................................27CLUTCH & TRANSMISSION..................................................................................................................31ELECTRICAL & STARTER/GEN............................................................................................................33ENGINE (GAS)........................................................................................................................................40FUEL.......................................................................................................................................................44IGNITION................................................................................................................................................46INSTRUMENTS......................................................................................................................................48MANUALS & PUBLICATIONS................................................................................................................49MOTORS (ELECTRIC)...........................................................................................................................50REAR AXLES & DIFFERENTIAL............................................................................................................56SOLENOIDS...........................................................................................................................................59SPEED CONTROL..................................................................................................................................61STEERING & SUSPENSION..................................................................................................................65SWITCHES & CIRCUIT BREAKERS......................................................................................................75SWITCHES (FORWARD/REVERSE).....................................................................................................77WHEELS & TIRES..................................................................................................................................79

MAIL ORDER FORM..........................................................................................................................................81

i

CLUB CAR

ACCESSORIESSport Side MirrorPrice: $25.64Part Number: AC128OEM Part Numbers -Item Description -Rally Type Side Mount SportMirror with black housing

5'' Round MirrorPrice: $31.20Part Number: AC129OEM Part Numbers -CU822167, 887246, ND 62331,80549Item Description -5" Round Flat Glass Mirror inblack metal housing with ballpivot mount bracket, NOTE:This is a factory item on someCushman and Nordskog carts.

Five Panel MirrorPrice: $24.38Part Number: AC130OEM Part Numbers -Item Description -Five Panel "Wink" Style Mirror,include universal mountingbracket kit our part numberAC132

Four Panel MirrorPrice: $29.15Part Number: AC131OEM Part Numbers -Item Description -Four Panel "Wink" Style Mirror,include universal mountingbracket kit our part numberAC132, Used on 2000 andnewer Club Car DS model

Universal MirrorBracketsPrice: $7.97Part Number: AC132OEM Part Numbers -Item Description -Universal mounting bracket kitour part number AC130 andAC131

Custom Mirror BracketsPrice: $5.27Part Number: AC133OEM Part Numbers -Item Description -Custom Mirror Brackets to fitAC130 Five Panel Mirror to1985 to 1994 E-Z-GO Marathonmodel and Four Panel Mirrornumber AC131 to 2000 andnewer Club car model DS

Mirror BracketsPrice: $5.27Part Number: AC135OEM Part Numbers -Item Description -Custom Mirror Brackets for1981 to 1999 Club Car DSmodels for installing 5 PanelMirror number AC130

Battery Anti-CorrosionRingsPrice: $3.69Part Number: BT161OEM Part Numbers -Item Description -Battery Post Anti-CorrosionRings with 5/8" hole forAutomotive Style Posts,Package of 12

Battery PostAnti-Corrosion RingsPrice: $3.98Part Number: BT163OEM Part Numbers -Item Description -Battery Post Anti-CorrosionRings with 3/8" hole for MarineStyle Posts, Package of 12

Bolt for J HookPrice: $0.95Part Number: SP860OEM Part Numbers -TD88-060-09, CC 7847Item Description -Bolt for Five Speed J Hook and2 hole Pomounting Dual cupHolder on 1993 and newer Club

CLUB CAR CLUB CAR 1

Car model DS. Steel Hex Screwmeasures 1/4"-20 threads by3/4" long

CLUB CAR ACCESSORIES

CLUB CAR ACCESSORIES 2

BATTERIES & CHARGERSBattery ChargerPrice: $465.47Part Number: BT100

OEM Part Numbers -HD66499-82, HD 66534-83A, CC1016433-01, EZ 16162-G3Item Description -Lester Automatic BatteryCharger, model # 9700, 36 Volt,20 amp output with crowsfootplug, replaces old manualchargers, has automatic shut offwhen batteries are charged,used on Harley Davidson, ClubCar, E-Z-GO, Cushman, Melex,Legend, Noland, Nordskog,Westinghouse, Pargo, TaylorDunn, Hyundai, and Yamahawith 36 volt systems and CrowsFoot receptacle

Fuse AssemblyPrice: $9.98Part Number: BT111

OEM Part Numbers -HD66515-76, CC 1012101, EZ31567-G1, L8776Item Description -30 Amp Fuse Assembly forHarley Davidson, 1995 andnewer Club Car 48 Volt,E-Z-GO, and many others withLester Charger model numbers6430, 6720, 7710, 7850, 8714,9032, 9611, 9695, 9700, 13165,14100, 14390, 17910 and othermodels, includes busbar andmounting hardware

Crowfoot Repair KitPrice: $20.28Part Number: BT102

OEM Part Numbers -Item Description -Crowfoot Plug Repair Kit forLester Charger used on 1965 to1981 Harley Davidson, alsoClub Car, E-Z-GO pre 1983,Cushman, Melex, Legend,Noland, Nordskog,Westinghouse, Pargo, TaylorDunn, Hyundai, and Yamahawith 36 volt systems and CrowsFoot receptacle

DC ReceptaclePrice: $14.04Part Number: BT101

OEM Part Numbers -HD66036-72, EZ 17756-G1, CC4107, 8257, 8428, CU 884937,ME 300618, LE 627701, NO610, ND 72174, TD 76-013-00,HY GB1-803700, YAJ14-86181-00-00, YAJ14-86181-01-00, YAJ22-86181-00, YAJN4-H61181-00Item Description -Crows Foot Style DCReceptacle for Battery ChargerPlug for use on HarleyDavidson, Club Car, E-Z-GO,Cushman, Melex, Legend,Noland, Nordskog,Westinghouse, Pargo, TaylorDunn, Hyundai, and Yamahawith 36 volt systems and CrowsFoot receptacle

DC Charger Cord, GrayPlugPrice: $44.37Part Number: BT103

OEM Part Numbers - HD66063-69A, 66063-69B, CC1013076, 1013688, 1013753,1016433-01, EZ 14835-G1,16152-G1, 16442-G1,

DC Charger Cord, YellowPlugPrice: $54.70Part Number: BT104

OEM Part Numbers -CC1012064, 1012100,1016433-04, EZ 16587-G1, LE9872, NO 610LCP, PA 3301,Item Description -

CLUB CAR BATTERIES & CHARGERS

CLUB CAR BATTERIES & CHARGERS 3

18636-G1, PA 4133, KA 769-73,NO 602, ND 72184, LE 9873,TD 79-566-11, 9000907Item Description -DC Chord Assembly with grayMolded Plastic Housing withTwo Prong Angled Crow FootPlug for Lester Charger used on1965 to 1981 Harley Davidson,Club Car, E-Z-GO pre 1983,Cushman, Melex, Legend,Noland, Nordskog,Westinghouse, Pargo, TaylorDunn, Karrior, Hyundai, andYamaha with 36 volt systemsand Crows Foot receptacle

DC Charger Cord with MouldedPlastic Yellow Housing withretractable Crowfoot AngledBlades for Lester Charger usedon Club Car, Columbia Par Car,E-Z-GO, Cushman, Melex,Legend, Pargo, and Yamaha

AC Charger CordPrice: $16.48Part Number: BT105

OEM Part Numbers - 66501-69Item Description -3 prong AC Cord for LesterBattery Charger models 6430,6720, 6730, 7710, 7850, 9080,9475, 9513, 9600, 9611, 9695,9700, 9800, 13110, 13165 andothers

Diodes with HeatsinkPrice: $40.46Part Number: BT107

OEM Part Numbers -HD66505-69, CC 1012119, CU815926Item Description -Heat Sink with two Press InDiodes for Harleys, Club Cars,Cushman and others with LesterCharger models 8600 and 8650,Diode Plate measures 3-5/8" by7-3/8"

Diodes and HeatsinkPrice: $20.48Part Number: BT108

OEM Part Numbers -HD66505-76, 66505-82, 66505-91,CC 1012102, 1012109,1015914, CU 886435, TD79-749-13, L 8385Item Description -Heatsink with Diodes for HarleyDavidson, Club Car 48 VoltChargers for 1995 and newer,also Cushman and Taylor Dunnand others with 36 and 48 voltLester Charger models 6430,6720, 6730, 7710, 7850, 8946,9027, 9028, 9032, 9611, 9695,9700, 9800, 13110, 13165,14100, 14390, 16500, and17910, NOTE: replacementdiodes are not available

Manual TimerPrice: $40.46Part Number: BT109

OEM Part Numbers -HD66057-69, CC 1012000,1012105, CU 815955, LE 9868,NO 604, 02002S, ND 71884, PA3300, TD 79-805-60, L2002Item Description -Clockwise Manual Timer forLester Battery Charger used onHarley Davidson, Club Car,Cushman, Karrior, Legend,Noland, Nordskog, Pargo,Taylor Dunn, and others, comeswith instruction sheet. NOTE:Fits the following Lester ManualChargers but not all are listed:36 volt models 3486, 3487,6720, 7745, 8946, 9028, 9032,9080, 9611, and 24 volt models6730, 9200, 9600, and 13165.NOTE: This is for 110 volt ACinput chargers only



AmmeterPrice: $21.94Part Number: BT110

OEM Part Numbers -HD66506-69, CC 1012097,1012106, L2000Item Description -Square Face 30 Amp Ammeterfor Lester Charger used onHarley Davidson, Club Car, andothers for Lester models 6720,8600, 8650, 8714, 8946, 9027,9028, 9032, 9611, 13165,includes insulated terminals,busbar, hardware andinstruction sheet, measures2-1/4" by 2-1/4"

Fuse AssemblyPrice: $11.31Part Number: BT112

OEM Part Numbers -Item Description -40 Amp Fuse Assembly wtthPlastic Cover for HarleyDavidson and many others withLester Charger models 9080,9475, 9513, 9600, and manyother models, includes bus barand mounting hardware

CapacitorPrice: $24.28Part Number: BT113

OEM Part Numbers -HD66509-69, CC 1012115, EZ11560-G2, 17077-G1,17122-G1, 28109-G1, CU823749, TD 79-902-10, L8415Item Description -Cannister type 20.5 mf (microfarad) Capacitor for HarleyDavidson, Club Car, 1994 andnewer E-Z-GO Powerwise andPowerwise Plus, also Cushmanand Taylor Dunn with LesterCharger models 8600 and 8650,measures 2-11/16" wide by3-1/4" tall

Circuit Breaker, 50 ampPrice: $9.96Part Number: SW101

OEM Part Numbers -HD66058-65, 74857-36, EZ11573-G1, 13163-G1,13164-G1, CC 1012005,1012450

Item Description -50 amp Circuit Breaker forLester battery charger on HarleyDavidson, E-Z-GO before TotalCharge, and Club Car, also willreplace 74857-67 diode onHarley Davidson speed controlon master drive control systemon 1969 to 1970 model DEC,1967 to 1971 model DE, and1979 to 1982 model MGIV, tworequired for master drive system.

Capacitor, 6 mfPrice: $29.16Part Number: BT114

OEM Part Numbers -HD66516-76, CC 1012095, CU823749, 825058, TD 79-902-10,ND 2390, 70165, 70355, 72165,LE 9864, NO 02390S, KA769-76, PA 7420Item Description -Cannister type 6 mf (microfarad) Capacitor for HarleyDavidson, Club Car, Cushman,Taylor Dunn,Westinghouse/Nordskog,Legend, Noland, Karrior, and

Voltage ReducerPrice: $198.87Part Number: EL260OEM Part Numbers -16511-G1,16874-G1Item Description -Voltage Reducer for all cartswith 24, 36, or 48 volt systems.Converts these voltages downto 12 volts for running lights,radios and other 12 voltaccessories. Has a high ampoutput of 25 amps peak.Includes heat shrink andmounting hardware



Pargo with either Mac Chargersor 36 Volt Lester Chargersmodels 6430, 6720, 6730, 7710,7850, 8946, 9027, 9028, 9032,9080, 9475, 9513, 9600, 9610,9695, 9700, 9800, 13110,13165, 14390, 17910

Charge Receptacle BezelPrice: $4.29Part Number: BT020

OEM Part Numbers - CC1013649Item Description -Charge Receptacle Bezel usedwith part number BT101 on1985 and newer Club Car, alsoNoland and other carts

Battery Anti-CorrosionRingsPrice: $3.69Part Number: BT161OEM Part Numbers -Item Description -Battery Post Anti-CorrosionRings with 5/8" hole forAutomotive Style Posts,Package of 12

Battery PostAnti-Corrosion RingsPrice: $3.98Part Number: BT163OEM Part Numbers -Item Description -Battery Post Anti-CorrosionRings with 3/8" hole for MarineStyle Posts, Package of 12

Charging FusePrice: $11.70Part Number: bt415OEM Part Numbers -1014516Item Description -Charging Fuse for 1985 to 2002Club Car, includes fuse, fuseholder and lens, 80 amp rating

Battery Cable, Black5-3/4''Price: $4.95Part Number: EL940

OEM Part Numbers - TD75-235-20Item Description -5-3/4" long 6 gauge BlackBattery Cable with 5/16" eyelet


OEM Part Numbers - YAJR1-H2149-00, JR1-H2149-01,HY GB1-802012, GB1-803012Item Description -7-1/2" long 6 gauge BlackBattery Cable with 5/16" eyelet

Battery Cable, Black 9''Price: $5.25Part Number: EL942

OEM Part Numbers - CU881995, 883077, DA 65723, LE262605, ME 300615, NO 565,ND A06BLK0090DD,A2568B62A09, PA 3029, YAJ14-82127-00, J14-82148-00,J56-H1890-00, J56-H2127-00,JG6-H1890-00, JG6-H1890-01Item Description -9" long 6 gauge Black BatteryCable with 5/16" eyelet

Battery Cable, Red 9''Price: $5.45Part Number: EL943

OEM Part Numbers - CC 7296,HD 70199-68C, CU 882661,883078, EZ 11893-G1,14611-G1, 30277-G1, JA557261, LE 626605, ME300615, NO 565, PA 3029Item Description -9" long 6 gauge Red BatteryCable with 5/16" eyelet





OEM Part Numbers -Item Description -10" long 6 gauge Black BatteryCable with 5/16" eyelet

OEM Part Numbers -Item Description -10" long 6 gauge Red BatteryCable with 5/16" eyelet


OEM Part Numbers - CC 7622,1010958, HD 70108-85, CU882947, HY GB1-802014GB1-802015, LE 621492,625144, ME 300611, NO561-12N, ND A06BLK0120BD,PA 3019Item Description -12" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - CC 7295,CU 835340, EZ 11888-G2,14610-G1, LE 621492, 625144,ME 300611, NO 561-12P, PA3019Item Description -12" long 6 gauge Red BatteryCable with 5/16" eyelet


OEM Part Numbers - CU814417, 882374, 882948,882954, 883186, NO 561-14N,YA JR1-H2127-00,JR1-H2127-01Item Description -14" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - CC 7263,DA 65706, HY GB1-802013, LE624779, ME 300610, NO561-16N, ND A06BLK0160DD,A2905B50A11Item Description -16" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - CU884116, EZ 11885-G4, JA557259, LE 624779, ME300610, NO 561-16PItem Description -16" long 6 gauge Red BatteryCable with 5/16" eyelet


OEM Part Numbers - CC 7294,8540, HY GB1-802034, LE624414, NO 561-18N, PA 3018Item Description -18" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - CC 7293,CU 835341, LE 624414, NO561-18P, PA 3018Item Description -18" long 6 gauge Red BatteryCable with 5/16" eyelet




Battery Cable SetPrice: $16.58Part Number: EL930



OEM Part Numbers - NO561-20P, ND A2905B50A14Item Description -21" long 6 gauge Red BatteryCable with 5/16" eyelet

OEM Part Numbers - CC1010958Item Description -Battery Cable Set for 1985 to1994 36 Volt Yamaha G2, G8,and G9, Also for 1981 andnewer Club Car model DS.Includes five 12" long six gaugecables


OEM Part Numbers - NDA2905B50A05, A2905B50A15,A2905B50A19Item Description -23" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - EZ11883-G1, 11884-G1,11885-G2 11888-G3,23540-G1, 11888-G3Item Description -23" long 6 gauge Red BatteryCable with 5/16" eyelet



Battery Cably, Red 24''Price: $7.80Part Number: EL959

OEM Part Numbers - CU887854, NO 561-24PItem Description -24" long 6 gauge Red BatteryCable with 5/16" eyelet


OEM Part Numbers - DA 65713,PA 3033Item Description -26" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - EZ14632-G1, PA 3033Item Description -26" long 6 gauge Red BatteryCable with 5/16" eyelet


OEM Part Numbers - EZ14632-G1, PA 3033Item Description -28" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - EZ11892-G4Item Description -28" long 6 gauge Red BatteryCable with 5/16" eyelet


OEM Part Numbers - CU886640, NO 561-30NItem Description -30" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - CU886645, DA 65875, EZ11891-G4, 11892-G1, NO561-30PItem Description -



30" long 6 gauge Red BatteryCable with 5/16" eyelet


OEM Part Numbers - LE621857, NO 561-32NItem Description -32" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - EZ11889-G1, 11890-G1, LE621857, CC 1019028-01Item Description -32" long 6 gauge Red BatteryCable with 5/16" eyelet



Battery Cable, Red42-1/2''Price: $17.55Part Number: EL971

OEM Part Numbers - CU881644Item Description -42-1/2" long 6 gauge RedBattery Cable with 5/16" Eyeletson both ends, fits Cushman andmany others

Battery Cable SetPrice: $18.25Part Number: EL930B

OEM Part Numbers - CC0107957-01Item Description -Battery Cable Set for 1995 andnewer 48 Volt Club Car modelDS. Includes five 14" long sixgauge cables

Give us a call!1 (360) 385-4868

Vintage Golf Cart Parts107 Louisa Street

Port Townsend, WA.98365



BEARINGS & SEALSSealPrice: $10.98Part Number: BE402

OEM Part Numbers - PA2227-33, JA 325472Item Description -Front Wheel Hub Seal for 1975and earlier Club Car, also motorseal on Pargo and Jacobsen.Dimensions: 1.381" O.D. by.812" I.D. by .254" width

A-Plate BushingPrice: $2.05Part Number: ST440OEM Part Numbers -7719Item Description -Inner and Outer A-PlateBushing for 1975 to 1992 ClubCar gas and electric models

Rear Axle & Front WheelBearingPrice: $14.82Part Number: BE400

OEM Part Numbers -CU835013, EZ 23519-G1, NOT-19, PA 2632, 3153, YA93306-00511, 93306-0513,93306-00518, 93306-00541,93306-00543, 93306-005Y1,93306-005Y3Item Description -Outer Rear Axle Bearing for1976 to 1984 Club Car, also fitsthe following with TerrillDifferentials, early rear axle onE-Z-GO, Cushman, Pargo,Noland, also Yamaha inputshaft bearing on 1993 andnewer electric G9 and G14,G16, G20, G21, G22, alsoYamaha front inner wheelbearing on 1982 to 2002 G1,G2, G8, G9, G14, G16, G19,G20, G21 and 2003 electricfront outer wheel bearing Note:Not available from Club Carseparately, .980" (25mm) I.D. by1.850" (47mm) O.D. by .470"(11.9mm) wide

Rear Axle SealPrice: $4.29Part Number: BE401

OEM Part Numbers - CC 7906,EZ 2633, CU 835022, LE 2633,NO T-38, PA 2633Item Description -Outer Rear Axle Seal for 1976to 1984 Club Car with Terrellrear differential, also earlyE-Z-GO, Cushman, Legend,Noland, Pargo with TerrellDifferential, Dimensions: 1.12"(28.6mm) I.D. by 1.84"(46.8mm) O.D. by .30" (7.7mm)wide, not available separatelyfrom Club Car

Bearing, Crankshaft &Rear AxlePrice: $15.12Part Number: BE111

OEM Part Numbers - CO83032-96, CC 7336, 1011291,1011317, 1012677, 1012685,1012726, 1013777, 1013793,EZ 26783-G01, 26811-G01,51051-G1, 73120-G07, TD80-504-00, CU 815093, 821292,823012, 823292, 824669,

Front Wheel SealPrice: $2.54Part Number: BE404

OEM Part Numbers - 1013135Item Description -Front Wheel Seal for 1982 andnewer gas and electric ClubCar, 1.940" (49.4mm) O.D. by1.070" (27.1mm) I.D. by .460"(11.8mm) wide

CLUB CAR BEARINGS & SEALS

CLUB CAR BEARINGS & SEALS 10

824704, 826681, 832412,832499, 835016, YA93306-20504, 93306-20509,93306-2050X, 93306-2013,93306-20517, 93306-20519,90336-20525, 93306-20529,93306-20541, NO T-28, NDA413A986H07, PA 1538Item Description -Crankshaft Bearing for 1982 to1995 Harley Davidson 2 cycleengine, fan side, also 1996 to2000 rear axle, Club Car DSrear axle 1984 to 1986 with Fujirear axle, E-Z-GO 2 cycle gascrankcase flywheel side, 1976to 1979 and 4 cycle gas inputshaft clutch side for 1994 andnewer and rear axle for 1991and newer, Yamaha rear axle1978 to 1994 G1, G2, G8, G9and 4 cycle gas input shaft from1985 to 1995 G2, G8, G9 andelectric input shaft from 1981 to1992 G1, G2, G8, G9, Cushmandifferential, also Noland,Nordskog, Pargo and TaylorDunn, .980" (24.9mm) I.D. by2.050" (51.9mm) O.D. by .590(14.9mm) wide


OEM Part Numbers - CC 7273,CU 807630, LE 3-3334Item Description -Front Wheel Bearing Seal for1976 to 1981 Club Car,Cushman, Legend, 1.100"(27.9mm) I.D. by 1.780"(45.3mm) O.D. by .460"(11.8mm) wide

Steering Bearing SetPrice: $27.59Part Number: BE103

OEM Part Numbers - HD57082-67, CC 1011401, EZ5574, 5575, CU 818902, TD18-307-53, 18-307-56,18-307-57, DA 40903, OTA-40903, PA 3082Item Description -Worm Shaft Bearing and RaceSet for Steering Box onHarley-Davidson 3 and 4 Wheel,Club Car 1976 to 1983, E-Z-GO,Cushman, Taylor Dunn, Davis,Otis, and Pargo. Dimensions ofRace: .88" (22.2mm) I.D. by1.53" (38.8mm) O.D. by .27"(6.9mm) W.

Wheel Bearing SetPrice: $9.47Part Number: BE106OEM Part Numbers - HD 9033,CC 7274, 7308 1011393, EZ11750-G1, 11752-G1,50908-G1, 1720008, 3523903,CU 385174, 548124, 548127,

Intermediate PinionBearingPrice: $8.19Part Number: BE707OEM Part Numbers - PA 3162,CC 7335, EZ 26785-G1, HD9038, CU 835011, NO T-18, YA93303-20421, HY



808088, 808089, LE 3-3339,ME 300339, ND 10357, TD80-015-00, 80-105-00, JA354735, 500534, 546638,546639, 593793, PA 3045, 3046Item Description -Front Wheel Bearing Set for1963 to 1987 Harley-Davidson 3Wheel, 1974 to 2003 Club Carfront wheel on DS 4 wheel carts,E-Z-GO 3 wheel 1967 andnewer, Cushman front wheel allcarts, Legend, Melex, Nordskog,also Westinghouse model 436,437, 438, 439, and model 139front wheel, Taylor Dunn,Jacobsen, Toro, Otis and Pargo3 wheel. Dimensions: .74"(18.7mm) I.D. by 1.8" (45.2mm)O.D. by .47" (12mm) W., innerrace width .66"

Item Description -Intermediate Pinion ShaftBearing Bearing, non sealed,open sided for 1965 to 1975Pargo with Terrill differential,Club Car located on oppositemotor input on 16 splinedifferentials and both sides ofthe pinion on some differentialswith taper shaft motors, E-Z-GOon 1991 and newer differentials,Harley, Cushman input shaft,also Noland and Hyundaidifferentials, Yamaha 1992 andolder electric G1, G2, G8, G9,7/8" I.D. bearing

Rear Axle BearingPrice: $11.61Part Number: BE406OEM Part Numbers - CC1012685, CO 83036-96, EZ26811-G01, TD 80-504-00Item Description -Inner Rear Axle Bearing for1984 to 1986 Club Car with Fujirear axle, 1996 and newerColumbia Harley rear axle, 1991and newer 4 cycle E-Z-GO rearaxle, and Taylor Dunntransmission bearing.

Intermediate PinionBearingPrice: $9.36Part Number: BE706OEM Part Numbers - PA 1538,CC 7330, EZ 26783-G01, YA93306-20529, HD 9032, CU815093, NO T-28Item Description -Intermediate Pinion ShaftBearing Bearing for 1969 to1975 Pargo with Terrilldifferential with 16 spline motor,also Club Car 1984 and newerfront opposite motor sideintermediate pinion shaftbearing, E-Z-GO 1991 andnewer 4 cycle gasdifferential,Yamaha 1992 andolder electric G1, G2, G8 outershaft or carrier on both sides,also Harley, Cushman, andNoland

Crankcase SealPrice: $5.56Part Number: BE412

OEM Part Numbers - 1012524Item Description -Crankcase Oil Seal for bothClutch and Flywheel Side on1984 to 1991 Club Car modelDS, Measures 1.96" (50mm)O.D. by 1.18" (30mm) I.D. by.31" (8mm) wide

Carrier Gear BearingPrice: $18.54Part Number: BE704OEM Part Numbers - PA 3155,CC 7330, 1013778, EZ26806-G01, YA 93306-00803,NO T-18Item Description -Open Sided Carrier GearBearing for Pargo 1965 to 1975with Terrill differential, also ClubCar 1976 to 1984 with Terrilldifferential, and 1984 and newerDS and Precedent with either



Kawasaki or Graziano reardifferentials, E-Z-GO 1991 andnewer 4 cycle gas, Yamaha1992 and older G1, G2, G8 andNolan. Dimensions: 1.57"(39.9mm) I.D. by 2.68"(68.1mm) O.D. by .58"(14.9mm) W.

Pinion BearingPrice: $12.87Part Number: BE705OEM Part Numbers - PA 3364,CC 7333, CU 835020, LE 3162,NO T-32Item Description -Motor Input Pinion Bearing for1969 to 1975 Pargo andCushman with Terrill differentialwith 16 spline motor, also ClubCar 1984 to 1986 motor sideintermediate gear with Fujidifferential, also Legend andNoland. Open on both sideswith snap ring, Dimensions:1.17" (29.8mm) I.D. by 2.16"(54.9mm) O.D. by .51"(12.9mm) W.

Steering Tube BushingPrice: $6.34Part Number: ST120OEM Part Numbers -HD 57067,57067-68, CC 7841, EZ 5568,1701337, 31772-G1, 50201-G1,CU 819924, 831135, JA546064, ME 300524, NO 280C,ND 12878, OT A-53952, PA3080Item Description -Upper Steering Tube Bushingfor Harley Davidson, gas andelectric, late 1968 model D gasafter serial number 680-10757to 1981 and 1969 to 1981 modelDC and D4, late 1968 to 1981model DE electric after serialnumber 68DE-6172, and 1969to 1970 model DEC, and 1977to 1981 electric model DE3, also1979 to 1982 electric modelMGIV, also fits Club Car 1976 to1984 electric, E-Z-GO 1965 to1970, Cushman, Jacobsen,Melex, Noland, Nordskog, Otis,and Pargo

Steering Tube GasketPrice: $1.55Part Number: ST121OEM Part Numbers -HD570670-68, CC 1012466, EZ16722-G1, CU 819923, DA53756, JA 555102, NO 280D,OT A-53756, PA 1727Item Description -Upper Steering Tube DustCover Gasket for HarleyDavidson, gas and electric, late1968 model D gas after serialnumber 680-10757 to 1981 and1969 to 1981 model DC and D4,late 1968 to 1981 model DEelectric after serial number68DE-6172, and 1969 to 1970model DEC, and 1977 to 1981electric model DE3, also 1979 to1982 electric model MGIV, alsofits Club Car 1976 to 1994,E-Z-GO 1965 to 1970,

Balace Shaft, Motor &Wheel BearingPrice: $9.95Part Number: BE125

OEM Part Numbers - HD 9031,30150-67, 90004-90, CC1011290, 1012877, EZ16918-G1, 23520-G1,27630-G13, JA 343667, TD80-201-00, TO 251-6, CU812009, 824753, 832498, YA93306-20304, 93306-20309,93306-20310, 93306-20314,93306-20316, 93306-20324,93306-20331, 93306-20345,903306-203X1,J56-H1857-00-00, HYGB1-801003Item Description -Front Inner Wheel Bearing for1983 and newer HarleyDavidson, also both sides of



Cushman, Davis, Jacobsen,Melex, Noland, Nordskog, Otis,and Pargo

Balancer Shaft on 1995 andnewer 4 cycle, Club Car gasbalancer shaft clutch side,camshaft flywheel from 1984 to1991 and electric motor brushend from 1981 and newer(except IQ system), E-Z-GOelectric motor brush end on1980 to 1996, also Jacobsen,Taylor Dunn, Toro, Cushman,also Yamaha front outer wheelbearing for G1 from 1978 to1981 and electric motor brushend on 1990 and newer G8, G9,G14, G16, G19 and G20, AlsoHyundai. Dimensions: .66"(16.8mm) I.D. by 1.57"(39.9mm) O.D. by .47"(11.9mm) W.


OEM Part Numbers -450567Item Description -Front Wheel Seal for pre 1976Club Car, 1-3/8" diameter

Rear Axle BearingPrice: $11.02Part Number: BE405OEM Part Numbers - CC1011291, CU 832499, TD80-207-00, ND 20013, PA 3055,HD 72380-72Item Description -Outer Rear Axle Bearing for1984 and newer Club Carmodels DS and Precedent,Cushman rear axle, TaylorDunn rear axle, Nordskog rearaxle, Pargo rear axle, andHarley motor com end bearingwith GE motor

Axle BushingPrice: $22.23Part Number: BE407OEM Part Numbers - 1014207Item Description -Axle Bushing for 1985 andnewer Club Car models DS andPrecedent with Kawasaki "K"transaxle

Rear Axle SealPrice: $6.15Part Number: BE408OEM Part Numbers - 1012683Item Description -Rear Axle Seal for 1984 to 1985Club Car with Fuji transaxle

Rear Axle SealPrice: $4.49Part Number: BE409OEM Part Numbers - 1013794Item Description -Rear Axle Seal for 1986 andnewer Club Car models DS andPrecedent

Bearing, Crankcase,Axle, Wheel, & MotorPrice: $16.68Part Number: BE126OEM Part Numbers - HD 9030,9034, 72381-72, 83269-79, EZ15488-G1, 51320-G1, CU605636, 808058, 821291,823011, 824703, 835011, YA93306-20401, 93306-20417,93306-20420, 93306-20421,93306-20437, 93306-20469,93306-204X0, J10-81856-10 TD



80-200-00, DA 56226, JA315947, ND 20383Item Description -Crankcase Bearing for 1963 to1981 Harley Davidson, forclutch and flywheel side, also1983 and newer outer frontwheel bearing on 4 wheelHarley, E-Z-GO motor bearing,Cushman rear axle bearing,Outer Wheel Bearing for 1982 to2002 Yamaha models G1, G2,G8, G9, G14, G16, G20, G21,and electric front wheel innerG22, also Electric Motor Bearingfor brush end on 1978 to 1991models G1 and G2, Also rearaxle bearing on Taylor Dunn,Davis, Jacobsen, and NordskogNOTE: Club Car used thisbearing on the front wheel in2003 on electric carts afterserial number AQ344-343603and on gas carts after serialnumber AG0343-342005.Dimensions: .78" (19.9mm) I.D.by 1.85" (47mm) O.D. by .5"(14mm) wide.

Upper Spindle BushingPrice: $2.75Part Number: ST449OEM Part Numbers -8067Item Description -Upper Bronze Spindle Bushing1979 and newer Club Car gasand electric model DS.

Lower Spindle BushingPrice: $2.65Part Number: ST450OEM Part Numbers -7048Item Description -Lower Bronze Spindle Bushing1979 and newer Club Car gasand electric model DS.

Short Delta A-plateBushingPrice: $1.25Part Number: ST457OEM Part Numbers -1016349Item Description -Short Sleeve Bushing for DeltaA-plate on 1993 and newer ClubCar gas and electric model DS.

Long Delta A-plateBushingPrice: $1.55Part Number: ST458OEM Part Numbers -1016350Item Description -Long Sleeve Bushing for DeltaA-plate on 1993 and newer ClubCar gas and electric model DS.

Black A-plate BushingPrice: $1.75Part Number: ST459OEM Part Numbers -1015583Item Description -Black Urethane Bushing forLower A-plate on 1992 only

Blue Upper & LowerA-plate BushingPrice: $1.25Part Number: ST460OEM Part Numbers -1016346Item Description -Blue Urethane Bushing for



Club Car gas and electric modelDS.

Upper and Lower Delta A-plateon 1993 and newer Club Cargas and electric model DS.

Brake Block SetPrice: $9.66Part Number: BK441OEM Part Numbers - 1010811,1010812, 1011402Item Description -Brake Block Set for 1981 andnewer Club Car model DS, Thisis a set of four, enough for onecart

Drive End St/GenBearing & Int. GearPrice: $8.49Part Number: BE142OEM Part Numbers - 6303DU,HD 30151-69, 30153-77, EZ16877-G1, 23521-G1,26872-G01, CC 1013001, YA93306-30317, J10-81158-10,HY GG1-801180Item Description -Drive End Bearing forStarter/Generator on 1972 to1995 Harley, E-Z-GO 1978 to1993 2 cycle and 1991 andnewer 4 cycle, also IntermediateGear Bearing on 1988 andnewer E-Z-GO electricTransaxle, also Drive EndBearing on Club Car, and 1978and newer Yamaha G1, G2, G8,G9, G11, G14, G16, G19, G20,G21, and G22, and Hyundai.Measures .67" I.D. by 1.25"O.D. by .55" wide

Commutator EndBearingPrice: $6.44Part Number: BE141OEM Part Numbers - 6202V,HD 30149-67, 30154-77, EZ16876-G1, 26871-G01, CC1013005, YA 93306-20226,J10-81157-10, ME 300406, HYGG1-801170Item Description -Commutator End Bearing forStarter/Generator on 1972 to1995 Harley, E-Z-GO 1978 to1993 2 cycle and 1991 andnewer 4 cycle, also Club Car,also 1978 and newer YamahaG1, G2, G8, G9, G11, G14,G16, G19, G20, G21, and G22,and Melex, and Hyundai.Measures .59" I.D. by 1.38"O.D. by .43" wide

Crankcase BearingPrice: $10.43Part Number: BE201OEM Part Numbers -EZ14521-G1, 24504-G1, CC1019281-01, YA 93306-20627,HY 86W-000030, Kohler231625Item Description -Crankcase Bearing for 1976 to1993 E-Z-GO, 2 cycle engine,Clutch side Cam Bearing for1984 to 1991 Club Car with 341cc 4-cycle engine, Fan SideCrankshaft Bearing for 1978 to1989 Yamaha G1, also 1991and newer Hyundai CrankshahftBearing and Kohler CrankshaftBearing. Dimensions: 2.450"OD, 1.175" ID, .630 width

Crankshaft BearingPrice: $16.19Part Number: BE411OEM Part Numbers - CC1012867, 1016565, YA93306-20610, 93306-20612,93306-20633, 93306-30610,

Give us a call!1 (360) 385-4868


Port Townsend, WA.



93306-30621, 93306-30622,93306-30630Item Description -Crankshaft Bearing for 1984 to1991 Club Car with 341 ccEngine and Clutch SideCrankshaft Bearing for 1978 to1996 Yamaha models G1, G2,G8, G9 and G14

98365



BELTSDrive BeltPrice: $28.08Part Number: BL400

OEM Part Numbers - 1012289

Item Description -Drive Belt for 1984 to 1987 ClubCar gas. Top quality OEMreplacement. 7/8" wide x 37-1/2"O.D.

Drive BeltPrice: $25.16Part Number: BL401

OEM Part Numbers - 1014081,1017188

Item Description -Drive Belt for 1988 to 1991 ClubCar gas (not for overhead valveengines). Top quality OEMreplacement. 1" wide x 37-3/4"O.D.

Drive BeltPrice: $30.12Part Number: BL402


Item Description -Drive Belt for 1992 and newerClub Car gas. Top quality OEMreplacement. 1" wide x 37-1/2"O.D.

Generator BeltPrice: $13.65Part Number: BL410


Item Description -Generator Belt for 1984 to 1987Club Car gas. Top quality OEMreplacement. 3/8" wide x 36-3/4"O.D.


OEM Part Numbers -1019167-01

Item Description -Generator Belt for 1997 andnewer Club Car gas. Top qualityOEM replacement. 1/2" wide x36-1/2" O.D.



Item Description -Generator Belt for 1988 to 1991and 1994 Club Car gas. Topquality OEM replacement. 3/8"wide x 32-3/4" O.D.



Item Description -Generator Belt for 1992 to 1996and 1995 to 1996 Club Car gas.Top quality OEM replacement.3/8" wide x 32-3/4" O.D.

Give us a call!1 (360) 385-4868



CLUB CAR BELTS

CLUB CAR BELTS 18

BODY, TRIM & SEATSTurf Floor MattPrice: $39.95Part Number: BD411OEM Part Numbers -Item Description -Spike Cleaning, CommercialGrade, Black Grass, Turf StyleFloor Matt for 1982 and newerClub Car

Floor MattPrice: $56.36Part Number: BD410OEM Part Numbers -1015032Item Description -Black Pebble Grain Floor Mattfor 1981 and newer, 44-1/8" by30-1/2"

48'' long TopPrice: $127.73Part Number: BD108

OEM Part Numbers -EZ12693-G1Item Description -Universal Three Rib Whitecross-link unbreakablepolyethylene Top, 42" wide by48" long, fits 1968 to 1982E-Z-GO and many other golfcarts

54'' long TopPrice: $138.19Part Number: BD109

OEM Part Numbers - EZ16811-G1Item Description -Universal Three Rib Whitecross-linked unbreakablepolyethylene Top, 42" wide by54" long, fits 1983 to 1994pre-Medalist E-Z-GO and manyother golf carts

Bolt for J HookPrice: $0.95Part Number: SP860OEM Part Numbers -TD88-060-09, CC 7847Item Description -Bolt for Five Speed J Hook and2 hole Pomounting Dual cupHolder on 1993 and newer ClubCar model DS. Steel Hex Screwmeasures 1/4"-20 threads by3/4" long

Give us a call!1 (360) 385-4868



CLUB CAR BODY, TRIM & SEATS

CLUB CAR BODY, TRIM & SEATS 19

BRAKESBrake Shoe SetPrice: $32.08Part Number: BK400

OEM Part Numbers -CC 7352,HD 41844-66, TD 41-601-00,ND 80229, OT A-35975, PA50-24-3198Item Description -Brake Shoe Set for pre 1974Club Car Electric, HarleyDavidson gas model DC from1966 to 1972 and electric modelDEC from 1969 to 1970, alsoTaylor Dunn, Nordskog, Pargoindustrial vehicles as well asOtis Westcoaster with LucasGirling hydraulic brakes. Liningsare 1 3/16" wide by 7" long. setof 2

Wheel CylinderPrice: $64.35Part Number: BK402

OEM Part Numbers -7357Item Description -Wheel Cylinder for pre 1974Club Car Electric with LucasGirling brakes.

Wheel Cylinder MountingKitPrice: $26.85Part Number: BK403

OEM Part Numbers -CC 7714,HD 41747-66Item Description -Wheel Cylinder Mounting Kit forpre 1974 Club Car Electric withLucas Girling cylinders andHarley Davidson gas model DCfrom 1966 to 1972 and electricmodel DEC from 1969 to 1970,also Taylor Dunn, Nordskog,and Pargo industrial vehicles aswell as Otis Westcoaster withLucas Girling hydraulic brakes

Wheel CylinderPrice: $69.42Part Number: BK404OEM Part Numbers -CC 8225,PA 4394Item Description -Wheel Cylinder for 1974 to 1980Club Car and Pargo Electricwith Mercury Hydraulic brakes.left side

Wheel CylinderPrice: $69.42Part Number: BK405OEM Part Numbers -CC 8224,PA 4393Item Description -Wheel Cylinder for 1974 to 1980Club Car and Pargo Electricwith Mercury Hydraulic brakes.right side

Master CylinderPrice: $73.42Part Number: BK406OEM Part Numbers -CC 7580,8719, 8996Item Description -Master Cylinder for 1974 to1980 Club Car Electric withMercury hydraulic brakes

Brake Spring SetPrice: $30.03Part Number: BK408

OEM Part Numbers -CC 7715,HD 41832-66, TD 85-205-00,ND 13558, OT 35107, PA

Brake Shoe SetPrice: $44.46Part Number: BK206

OEM Part Numbers - EZ23364-G1, 23398-G1,27249-G01, CC 1018232-01,

CLUB CAR BRAKES

CLUB CAR BRAKES 20

50-243199, 50-24-3200Item Description -Brake Shoe Return Spring Setfor pre 1974 Club Car Electric,also Harley Davidson, TaylorDunn, Nordskog, Otis, Pargo,with Lucas Girling hydraulicbrakes, set of two, top springmeasures 4-3/8", bottom spring3-7/8"

YA J17-25330-00,J17-25340-00, J17-W2536-00,J55-W2536-00Item Description -Brake Shoe Set of 4 Shoes for1986-1/2 to 1996 E-Z-GO, 1995and newer Club Car, 1982 to1993 Yamaha G1, G2, G8, G9,also Hyundai HGB1, HGB1Aand Jacobsen, Lining is 1-3/16"wide by 6" long. NOTE: 1996E-Z-GO electric was a split yearand used either this or itemnumber BK207

Brake CablePrice: $19.31Part Number: BK425

OEM Part Numbers - 1011125,1011403, 1016761-01Item Description -Brake Cable for 1981 to 1999Club Car, 41-1/4" long

Brake Return SpringPrice: $6.05Part Number: BK212OEM Part Numbers - EZ17290-G1, CC 1011314,1011464, CO 41816-86, YA90506-26191, HY GCI-303280,LE 5480Item Description -Brake Shoe Return Spring for1982 to 1986-1/2 E-Z-GO usedtop and bottom, on 1986-1/2 to1996 E-Z-GO used closest toanchor, Club Car 1980 andnewer, Columbia Harley 1986and newer, Yamaha 1979 to1992 G1, G2, G8, G9, Hyundai1990 and newer, Jacobsen,Legend, 17 coils 3-3/4" long br>

Brake DrumPrice: $35.49Part Number: BK219OEM Part Numbers - EZ17082-G1, 17082-G2, CC1011137, 1017911-01, CO41815-86, YA J10+46521-00,J17-46521-00, J55-G6521-00,J55-G6521-10-00Item Description -Brake Drum for 1981 and newerE-Z-GO gas and electric, ClubCar 1981 to 1994, ColumbiaHarley 1986 to 1995, Yamaha1982 to 2003, 4 hole 4 boltpattern, Dimensions: 6.28" I.Dby 1.34" machined brake shoesurface width

Brake SpringPrice: $5.07Part Number: BK410OEM Part Numbers -CC1011466, CO 41817-86, EZ17291-G1, YA J10-27281-00-00Item Description -Flat Spring Steel U ShapedBrake Shoe Hold Down Springfor 1981 and newer Club CarElectric, also Columbia Harley1986 to 1994, E-Z-GO 1982 andnewer, Yamaha 1978 to 1991G1, G2, G8, G9 . NOTE: Not foruse on Bendix brake system.

Brake Shoe (set of 4)Price: $41.95Part Number: BK108

OEM Part Numbers - HD41819-86, HD 41819-86A,

Brake ShoePrice: $11.45Part Number: BK204

OEM Part Numbers -22517-G1,23354-G1, 27250-G01

CLUB CAR BRAKES

CLUB CAR BRAKES 21

5479, CC 1011296, 1011463,1011463-02, 1015757, EZ22517-G1, 23395-G1,23396-G1, 23398-G1,27294-G01, 17429-G1, YAJ10-25330-00, J10-W2536-00,J10-W2536-01Item Description -Columbia gas or electric, 1986to 1989, Club Car, 1981 to1994, E-Z-GO, 1982 to1986-1/2, Yamaha, 1978 to1981 G1, also Legend, Bondedlining, 1-3/16" wide x 6" long. 4per set

Item Description -Trailing Brake Shoe for1986-1/2 to 1996 E-Z-GO, ClubCar 1995 and newer, Yamaha1982 to 1993 G1, G2, G8, G9,Hyundai HGB1, HGB1A andJacobsen, NOTE: this shoegoes towards the rear of thecart, Lining is 1-3/16" wide by 6"long. NOTE: 1996 E-Z-GOelectric was a split year andused either this or item numberBK207

Brake ShoePrice: $11.45Part Number: BK205

OEM Part Numbers -EZ27251-G01Item Description -Leading Brake Shoe Shoe for1986-1/2 to 1996 E-Z-GO, ClubCar 1995 and newer, Yamaha1982 to 1993 G1, G2, G8, G9,Hyundai HGB1, HGB1A andJacobsen, NOTE: this shoegoes towards the front of thecart, Lining is 1-3/16" wide by5-7/8" long. NOTE: 1996E-Z-GO electric was a split yearand used either this or itemnumber BK207

Brake Shoe SetPrice: $49.24Part Number: BK202

OEM Part Numbers - CC 8227,8638, 1016556, EZ 4395, PA4395, 8638Item Description -Brake Shoe Set for Club Car1974 to 1980, and old E-Z-GOand Pargo industrial carts withMercury hydraulic brakes. Liningis 1-1/2" wide by 6-5/8" long. setof 4

Brake Return SpringPrice: $5.75Part Number: BK213OEM Part Numbers - EZ23359-G1, CC 1018163-01-1/2,YA 90506-20281, HYGCI-303290Item Description -Brake Return Spring for1986-1/2 to 1996 E-Z-GO, ClubCar 1980 and newer and 1995and newer, DS and Precedent,Yamaha 1979 to 1989 G1 and1985 to 1992 G2, G8, G9,Hyundai 1990 and newer, alsoJacobsen, 3-3/16" long, 14 coilhas 1-7/16" hook on one endand 3/4" on other, used closestto adjuster

Brake Spring KitPrice: $12.87Part Number: BK233OEM Part Numbers - 27944-G1Item Description -Brake Spring Kit for 1997 andnewer E-Z-GO, Club Car 2000and newer, Yamaha 1993 andnewer G11, G14, G16, G19,also Melex models 512 and 625with Bendix Brakes. NOTE:includes upper and lower returnsprings, adjuster spring, two cupand spring retaining assemblieswith pins

CLUB CAR BRAKES

CLUB CAR BRAKES 22

Clevis PinPrice: $0.54Part Number: BK265OEM Part Numbers -EZ10386-G3, CC 1010829, HD41841-63, TD 96-773-00, DA10992, JA 594004, KA 996-11,LE 6090, ME 300785, ND12868, PA 6090Item Description -Clevis Pin for 1976 and newerE-Z-GO Brake Cables, Club Car1981 and newer, also ColumbiaHarley, Taylor Dunn, Davis,Jacobsen, Karrior, Legend,Melex, Nordskog, Pargo, 5/16"diameter by 1" long

Hold Down PinPrice: $2.15Part Number: BK409OEM Part Numbers -CC1011466-1/2, HD 41817-86, EZ17292-G1, YA J10-27282-00-00Item Description -Brake Shoe Hold Down Pin for1981 and newer Club Car gasand electric models DS andPrecedent, also ColumbiaHarley 1986 to 1994, E-Z-GO1982 and newer, Yamaha 1978to 1992 G1, G2, G8, G9 .NOTE: Not for use on Bendixbrake system.

Retaing RingPrice: $0.34Part Number: BK423OEM Part Numbers -CC 764,7644, 1011779, HD 11035, CU111849, 510487, EZ 12305-G1,JA 556132, LE 2613432Item Description -Brake Cable E-Type RetainingRing for 1981 and newer ClubCar model DS, Also fits BrakeCables on Columbia ParCar/Harley Davidson, Cushman,1977 and newer E-Z-GO, aswell as Jacobsen and Legend

Brake Return SpringPrice: $6.65Part Number: BK413OEM Part Numbers -1019330-01Item Description -Brake Return Spring for 1987 to1998 Club Car model DS, 4"long

Brake Return SpringPrice: $5.95Part Number: BK414OEM Part Numbers - 1013531Item Description -Brake Return Spring for 1988 to1998 electric and all 1999 andnewer Club Car model DS ,2-1/2" long

Brake Equalizer RodPrice: $8.68Part Number: BK421OEM Part Numbers - 1010808Item Description -Brake Equalizer Rod for 1981 to1997 Club Car model DS

Brake Equalizer RodPrice: $20.97Part Number: BK422OEM Part Numbers - 1019531Item Description -Brake Equalizer Rod for 1998 to2001 Club Car model DS

Brake CablePrice: $22.72Part Number: BK426OEM Part Numbers - 1019907,1020221-01Item Description -Brake Cable for 2000 and newerClub Car model DS

Brake CablePrice: $40.95Part Number: BK427OEM Part Numbers -1025575-01Item Description -Right Passenger Side BrakeCable for 2004 and newer Club

Brake CablePrice: $40.95Part Number: BK428OEM Part Numbers -1025575-01Item Description -Left Driver Side Brake Cable for2004 and newer Club Car

CLUB CAR BRAKES

CLUB CAR BRAKES 23

Car Precedent model, 49" long,includes BK265 Clevis Pin andBK429 Bowtie Locking Pin

Precedent model, 37-1/2" long,includes BK265 Clevis Pin andBK429 Bowtie Locking Pin

Brake Cable EqualizerPrice: $9.07Part Number: BK424OEM Part Numbers - 1010809,1010814, 1017271Item Description -Brake Cable Equalizer for 1984to 1999 Club Car model DS

Brake Pedal KitPrice: $91.16Part Number: BK440

OEM Part Numbers - 1011406,1019540-01Item Description -Brake Pedal Kit for 1981 to1999 Club Car model DS

Brake Block SetPrice: $9.66Part Number: BK441OEM Part Numbers - 1010811,1010812, 1011402Item Description -Brake Block Set for 1981 andnewer Club Car model DS, Thisis a set of four, enough for onecart

Brake StopPrice: $3.52Part Number: BK442OEM Part Numbers - 1010878Item Description -Brake Pedal Stop for 1981 andnewer Club Car model DS

Brake Pedal PadPrice: $3.72Part Number: BK443OEM Part Numbers - 1013869Item Description -Brake Pedal Pad for 1981 andnewer Club Car model DS

Hill Brake Pedal PadPrice: $1.75Part Number: BK445OEM Part Numbers - 1013870Item Description -Hill Brake Pedal Pad for 1981and newer Club Car model DS

Brake Pedal PadPrice: $4.49Part Number: BK446OEM Part Numbers -1025591-01Item Description -Brake Pedal Pad for 2004 andnewer Club Car Precedentmodel

Hill Brake Pedal PadPrice: $3.75Part Number: BK447OEM Part Numbers -1025590-01Item Description -Hill Brake Pedal Pad for 2004and newer Club Car Precedentmodel

Push NutPrice: $0.32Part Number: BK448OEM Part Numbers - 1011650,1013876Item Description -Push Nut for Hill Brake PedalPin for 1980 and newer ClubCar model DS

Pivot BushingPrice: $0.69Part Number: BK449OEM Part Numbers - 1032Item Description -Hill Brake Pivot Bushing for1980 and newer Club Car modelDS

Hill Brake Rod & Pawl KitPrice: $15.51Part Number: BK450OEM Part Numbers - 1011404,1016173, 1010563, 1010804Item Description -Hill Brake Rod and Pawl Kit for1981 to 1998 Club Car modelDS

Hill Brake Rod & Pawl KitPrice: $16.87Part Number: BK451OEM Part Numbers - 1017322,1011877-02, 1019185-01Item Description -Hill Brake Rod and Pawl Kit for1999 and newer Club Car modelDS

CLUB CAR BRAKES

CLUB CAR BRAKES 24

Hill Brake Latch KitPrice: $15.51Part Number: BK452OEM Part Numbers - 1011876,1011877, 1010796, 1011404Item Description -Hill Brake Latch Kit for 1981 andnewer Club Car model DS

Hill Brake SpringPrice: $1.12Part Number: BK453OEM Part Numbers - 1010933Item Description -Hill Brake Spring for 1981 andnewer Club Car model DS

Hill Brake RodPrice: $7.02Part Number: BK454OEM Part Numbers - 10109804Item Description -Hill Brake Rod for 1981 andnewer Club Car model DS

Push NutPrice: $0.43Part Number: BK455OEM Part Numbers - 1010877Item Description -Hill Brake Rod Push Nut for1981 and newer Club Car modelDS

Rod Ball JointPrice: $2.34Part Number: BK456OEM Part Numbers - 1010932Item Description -Hill Brake Rod Ball Joint for1981 and newer Club Car modelDS

Hill Brake Rod SleevePrice: $0.37Part Number: BK457OEM Part Numbers - 1010805Item Description -Hill Brake Rod Sleeve for 1981and newer Club Car model DS

Cotter PinPrice: $0.27Part Number: BK458OEM Part Numbers - 1010932Item Description -Hill Brake Rod Stainless SteelCotter Pin for 1981 and newerClub Car model DS

Brake Backing PlateAssemblyPrice: $79.97Part Number: BK216OEM Part Numbers -17081-G2,22997-G2, 27427-G02,27942-G02, 27947-G02,70732-G02, 70793-G02,72422-G02, CC 1018233-01,YA JN3-F7280-00,JN6-F7280-03, J17-27208-00,JN6-F7280-03-00Item Description -Right Passenger Side CompleteBrake Backing Plate Assemblyfor 1982 and newer E-Z-GO,1995 and newer Club Car, and1982 to 2006 Yamaha, includesbrake shoes, brake springs,adjuster, actuating lever anddust cover

Brake Backing PlateAssemblyPrice: $79.97Part Number: BK217OEM Part Numbers -17081-G1,22997-G1, 27427-G01,27942-G01, 27947-G01,70732-G01, 70793-G01,72422-G01, CC 1018233-02,YA JN3-F7290-00,JN6-F7290-03, J17-27209-00,

Brake DrumPrice: $43.39Part Number: BK418OEM Part Numbers -1017911-01Item Description -Brake Drum for 1995 and newerClub Car model DS

CLUB CAR BRAKES

CLUB CAR BRAKES 25

JN6-F7290-03-00Item Description -Left Drivers Side CompleteBrake Backing Plate Assemblyfor 1982 and newer E-Z-GO,1995 and newer Club Car, and1982 to 2006 Yamaha, includesbrake shoes, brake springs,adjuster, actuating lever anddust cover

CLUB CAR BRAKES

CLUB CAR BRAKES 26

BRUSHES & SPRINGSBrush SetPrice: $40.37Part Number: BR102OEM Part Numbers - HD70491-63, 72367-72, CC 7363,8089, 8785, EZ 50278-G1,72368-G01, CU 807329,824251, 882960, TD 70-100-00,ME 500117, PA 3365-3, OTA-20663, WE 20663,A2623A54H02, A2623A54H03Item Description -Brush set for GE Motors usedon 1963 to 1971 HarleyDavidson models DE, DEF,DEC and 1972 to 1975 modelsDE and DE4, Club Car pre1980, E-Z-GO 1965 to 1972,also Cushman, Taylor Dunn,Melex pre 1985 models 102,202, 112, 212, 152, 252, andearly 412 with band brake onmotor, also Pargo as well asWestinghouse Motors used on1965 to 1976 WestinghouseMarketeer models 436, 436G,437 and 437A, and 529 Chariot,also Otis, Nordskog and othersusing Westinghouse motors (setof 4), length 1-5/8" long, 5/8"wide, 1/2" deep with springhook. NOTE: Used with both GEand Westinghouse motors

Brush SetPrice: $53.24Part Number: BR101OEM Part Numbers - HD70491-73, CC 7363, EZ15634-G1, 51318-G1, CU882960, 883663, TD 70-101-00,ND 20753, PA 2227-3, NOM-14, OT A-56224Item Description -Brush Set for GE Motors usedon Harley Davidson model DE3from 1977 to 1978 and modelDE40 from 1976 to 1978, ClubCar 1976 to 1980, E-Z-GO 1973to 1979, HMK Marketeer models438 and 439, Cushman, TaylorDunn, Nordskog, Pargo, Nolandand Otis .(set of 4), length1-3/16" long by 5/8" wide by 1/2"thick.

Brush AssemblyPrice: $58.11Part Number: BR100OEM Part Numbers - HD83283-86, CC 1011410,1011282, ME 520108, CU886026, TD 70-104-00, LE5561-200, ND 20953, HYGB1-801062Item Description -Brush Assemblies for GEmotors used on 1986 to 1990Harley-Davidson, Club Car 1980to 1993 36 volt, Melex 1985 andnewer models 412, 512, and625, Cushman, Taylor Dunn,Legend, Nordskog and Hyundai.length 1-7/16" long, 5/8" wide,1/2"deep. Set includes twoassemblies.

Brush HolderPrice: $64.47Part Number: BR205OEM Part Numbers -EZ16916-G1, 16916-G2, CC1011284, HD 83284-86, LE5561-1Item Description -Brush Holder with Springs for1980 to 1992 E-Z-GO with G.E.Motor, Club Car 1984 to 199336 volt, Columbia Harley 1986to 1990, and Legend

CLUB CAR BRUSHES & SPRINGS

CLUB CAR BRUSHES & SPRINGS 27

Brush, Traction MotorSetPrice: $45.24Part Number: BR103OEM Part Numbers - HD82918-79, CC 1011332,1011424, YA J14-81811-10,Item Description -Brush Set for late 1979 to 1982Harley Davidson model DE3with Hitachi Motor only, alsoClub Car 1980 to 1984, andYamaha G1 and G2 . (set of 4),length 1-1/8"long, 11/16" wide,5/8"deep.

Brush SpringPrice: $5.27Part Number: BR105OEM Part Numbers - HD72383-66, EZ 50280-G1, CU814289, TD 85-401-00, ME500115, ND 20433, PA 3365-5Item Description -Pull Type Brush Spring for GEMotors used on 1963 to 1971Harley Davidson models DE,DEF, DEC and 1972 to 1973models DE and DE4, alsoE-Z-GO, Club Car pre 1980,Cushman, Taylor Dunn, Melexpre 1985 models 102, 202, 112,212, 152, 252, and early 412with band brake on motor, AlsoWestinghouse Marketeermodels 436, 436G, 437 and437A and 529 Chariot, andNordskog, and Pargo .

Brush Set,Starter/GeneratorPrice: $23.45Part Number: BR110

OEM Part Numbers - HD30422-69, 30443-77, CC1013023, 1014699,1018693-01, EZ 16888-G1,26658-G01, YA J10-81111-10,J38-81111-10, JF2-81111-00,JF7-81111-00, CG1-801090Item Description -Brush Set for Starter/Generatoron 1967 and newer Harley withHitachi style Starter/Generator,Club Car 1984 to 1996, E-Z-GO1980 to 1993, Yamaha 1978and newer G1, G2, G8, G9,G11, G14, G16, G20, G21, G22,Hyundai 1991 and newer. 1"long by 17/32" wide by 7/32"thick

Brush SetPrice: $37.44Part Number: BR107OEM Part Numbers - HD70491-73, 82842-86, CC 7363,EZ 15445-G1, 15634-G1, PA2227-3, TD 70-105-00, NR20753, DA 56224Item Description -Brush Set for GE Motors withcable lead crossovers used onHarley Davidson from 1986 to1990, Club Car 1981 to 1985,E-Z-GO, Pargo, Taylor Dunn,Nordskog and Davis.(set of 4),length 1-7/16" long by 5/8" wideby 1/2" thick. NOTE: similar toBR101 except this brush has agroove in the top for the brushspring

Brush SpringPrice: $2.40Part Number: BR104OEM Part Numbers - HD83287-86, CC 1011411, EZ15446-G1, CU 824754, TD85-412-00, DA 56225, LE2227-5, NO M-12, ND 10556,OT A-56225, PA 2227-5Item Description -Brush Spring for G.E. Motorused byColumbia/Harley-Davidson,

Brush SpringPrice: $5.76Part Number: BR106OEM Part Numbers - HD82919-79, CC 1011420, YAJ14-81813-10Item Description -Brush Spring for late 1979 to1982 Harley Davidson modelDE3 and MGIV, with HitachiMotor only, also Club Car 1980to 1984 and Yamaha G1 andG2 with Hitachi Motor



Club Car 1984 and newer,E-Z-GO new style G.E. motor,HMK Marketeer models 438 and439, Melex 1985 and newermodels 412, 512, and 625, alsoCushman motor brush springand speed board brush spring,Taylor Dunn, Davis, Legend,Noland, Nordskog, Otis, Pargo,and Yamaha G8, G9, G14, G16.

Brush Holder withSpringsPrice: $87.79Part Number: BR116OEM Part Numbers - HD82916-79, 82919-79, CC1011326, 1011420, YAJ14-81813-10Item Description -Brush Holder with Springs forlate 1979 to 1982 HarleyDavidson model DE3 and MGIVwith Hitachi Motor only, alsoClub Car 1980 to 1984, andYamaha G1 and G2.

Brush HolderPrice: $32.17Part Number: BR111OEM Part Numbers - HD30351-77, CC 1013011, EZ16887-G1, YA JF2-81119-00 ,HY GG1-801080Item Description -Starter Generator Brush Holderwith Brushes and Springs for1972 to 1995 Harley Davidsonwith Hitachi Starter Generatorsonly, Also 1984 to 1995 ClubCar, and 1978 to 1993 E-Z-GO,and 1985 to 2007 Yamaha G2,G3, G5, G8, G9, G11, G14,G16, G20, G21, and G22, alsoHyundai with HitachiStarter/Generator

Motor InsulatingBushing KitPrice: $11.31Part Number: MT117OEM Part Numbers -HD82837-86, CC 1011407, CU824711, EZ 15437-G1, DA56232, LE 2227-37, NO M-4Item Description -G.E. Motor Insulating BushingKit for G.E. Motor with SquareInsulating Bushing which is.227" thick with .335" hole forold style GE Motors used onHarley Davidson, 1984 to 1993Club Car, Cushman, E-Z-GO,Davis, Noland, and others,Includes the plastic squarebushing, two fiber washers, onewith a .330" hole and the otherwith a .475" hole plus one 5/16"steel washer and one 5/16"serrated nut.

Brush Holder AssemblyPrice: $99.87Part Number: BR204OEM Part Numbers - EZ15444-G1Item Description -Complete Brush HolderAssembly with Brushes, Springsand Cable Crossovers withStuds for G.E. motor with cablebrush crossovers for E-Z-GO,Harley-Davidson, Cushman,Taylor Dunn, Nordskog, Otis,and Pargo.

Fiber WasherPrice: $2.45Part Number: MT112OEM Part Numbers -HD83260-75, 83289-86, CU

Fiber WasherPrice: $2.85Part Number: MT113OEM Part Numbers -HD83256-75, 83288-86, CU



823015, 824710, EZ 15442-G1,50309-G1, 51330-G1, DA56236, NO M-13, PA 2227-11,ND 70621, 70771Item Description -Round Fiber Washer for oldstyle GE Motors used on HarleyDavidson, Cushman, E-Z-GO,Davis, Noland, Pargo, Nordskogand others, has .475 hole, goeson inside where stud field studor brush stud goes through thebrush housing

814316, 824718, EZ 15438-G1,50289-G1, 51327-G1, DA56233, NO M-6, LE 2227-38,ND 70611, PA 2227-13,3365-13Item Description -Round Fiber Washer for oldstyle GE Motors used on HarleyDavidson, Club Car, Cushman,E-Z-GO, Davis, Noland, Otis,Legend, Taylor Dunn and Pargoand others, has .330 hole, goeson outside where field stud orbrush stud goes through thebrush housing

BR206Price: $60.45Part Number: BR206OEM Part Numbers - EZ16917-G1, 27630-G05, CC1011282, 1011410, HD83283-86, CU 886026, TD70-104-00, ND 20953, LE5561-2, HY GB1-801062Item Description -Brush Set with Stud for EarlyStyle G.E. Motor for 1980 to1992 E-Z-GO, 1980 to 1993Club Car, Harley, Cushman,Taylor Dunn,Nordskog/Marketeer, Legend,and Hyundai. Dimensions:1-7/16" long by 5/8" wide by 1/2"thick

Give us a call!1 (360) 385-4868





CLUTCH & TRANSMISSIONDriven Clutch BushingPrice: $16.77Part Number: CL421

OEM Part Numbers - 1012834Item Description - DrivenClutch Bushing for 1984 to 1989Club Car

Driven Clutch AssemblyPrice: $256.04Part Number: CL420

OEM Part Numbers - 1012288Item Description - SalsburyDriven Clutch Assembly for1984 to 1987 Club Car. NOTE:Not available from Club Car


OEM Part Numbers -1016360-01Item Description - SalsburyDriven Clutch Assembly for1988 to 1996 Club Car.

Driven Clutch Cam KitPrice: $67.96Part Number: CL423

OEM Part Numbers - 1017755Item Description - SalsburyDriven Clutch Cam Kit for 1988to 1996 Club Car, Includes Camand Spring

Driven Clutch Button KitPrice: $14.43Part Number: CL424

OEM Part Numbers - 1014454Item Description - DrivenClutch Button Kit for OEMClutch on 1988 and newer ClubCar DS and Precedent models.


OEM Part Numbers -1018340-01Item Description - DrivenClutch Assembly for 1997 andnewer Club Car DS andPrecedent models.

Drive Clutch PullerPrice: $49.87Part Number: CL400OEM Part Numbers - 1014496Item Description - Drive ClutchPuller Bolt for Club Car from1988 and newer DS andPrecedent models with FactoryDrive Clutch.

Drive Clutch PullerPrice: $5.95Part Number: CL400OEM Part Numbers - 1012803Item Description - SalsburyDrive Clutch Puller Bolt for ClubCar DS and Precedent modelswith after market Salsbury DriveClutch.

Salsbury Drive ClutchPrice: $393.90Part Number: CL404OEM Part Numbers - 1012287Item Description - SalsburyDrive Clutch for Club Car from1984 to 1987 DS model.

Salsbury Drive ClutchPrice: $327.99Part Number: CL405OEM Part Numbers - 1014449Item Description - SalsburyDrive Clutch for Club Car from1988 to 1999 DS model, NOTE:Not Available from Club Car

Drive ClutchPrice: $597.23Part Number: CL407OEM Part Numbers -1018339-04Item Description - Drive Clutchfor 1988 and newer Club Carindustrial model FE350.

Drive ClutchPrice: $323.99Part Number: CL408OEM Part Numbers -1016378-02, 1016378-03,1016378-05Item Description - SalsburyDrive Clutch for 1992 to 1996Club Car.

CLUB CAR CLUTCH & TRANSMISSION

CLUB CAR CLUTCH & TRANSMISSION 31

Drive Clutch Weight KitPrice: $50.31Part Number: CL409OEM Part Numbers - 1016801Item Description - Weight Kitfor Factory OEM Drive Clutchon 1992 and newer Club Carmodels DS and Precedent.

Drive ClutchPrice: $468.23Part Number: CL410OEM Part Numbers -1019339-02Item Description - FactoryOEM Drive Clutch for 1997 andnewer Club Car models DS andPrecedent.

Drive ClutchPrice: $348.66Part Number: CL411OEM Part Numbers -1019339-02Item Description - SalsburyDrive Clutch replaces FactoryOEM Drive Clutch on 1997 andnewer Club Car models DS andPrecedent.

Drive ClutchPrice: $663.13Part Number: CL412OEM Part Numbers -1031854-01Item Description - Drive Clutchfor 2004 to 2006 Club Carmodels Carryall 294/XRT1500.

Drive ClutchPrice: $468.21Part Number: CL413OEM Part Numbers -1018339-08Item Description - Drive Clutchfor 2005 Club Car modelsXRT1200 and 1200SE.

Drive Clutch Button KitPrice: $14.43Part Number: CL406OEM Part Numbers - 1014453Item Description - Drive ClutchButton Kit for Club Car for 1988and newer DS and Precedentmodels with Factory OEM DriveClutch.

CLUB CAR CLUTCH & TRANSMISSION

CLUB CAR CLUTCH & TRANSMISSION 32

ELECTRICAL & STARTER/GENVoltage RegulatorHitachi StylePrice: $38.47Part Number: EL107OEM Part Numbers - HD74509-76, 74510-85A,74513-76, CC 1012422, EZ16530-G1, YA J10-81910-10,HY GG1-803100Item Description -Hitachi Style Voltage Regulatorfor 1972 to 1994Columbia/Harley-Davidson 2cycle, 1984 to 1991 Club Car,1980 to 1994 E-Z-GO 2 cyclegas model X444 Marathon,1978 to 1990 Yamaha G1, G2,G9, and Hyundai 1991 andnewer. Voltage regulator for usewith Hitachi Starter Generators.

Commutator CoverPrice: $60.16Part Number: EL105OEM Part Numbers - HD30110-77, EZ 16885-G1,16886-G1, CC 1012993,1018764-01, YA J10-81166-10,HY GG1-801060Item Description -Rear Commutator Cover for theBrush End of theStarter/Generator for 1972 to1995 Columbia/HarleyDavidson, 1978 to 1993 E-Z-GOwith 2 cycle engine, 1984 to1995 Club Car, 1978 to 2002Yamaha G1, G2, G8, G9, G14,and G16, Also Hyundai withHitachi style Starter/Generator

Micro SwitchPrice: $3.45Part Number: SW400OEM Part Numbers -CC1014805, 1014807, 1014887,CU 825217, 829754, 832719,NO 531-82Item Description -Three Terminal Micro Switch forAccelerator Speed Switch on1970 to 1995 Club Car and gascomponent box on 1984 andnewer Club Car as well as theForward and Reverse Switch on1984 and newer gasoline ClubCars, also Cushman Forwardand Reverse Switch as well asFoot Switch Speed Control on36 volt Cushman Titan andMinute Miser, also used onNoland

Micro SwitchPrice: $3.12Part Number: SW401OEM Part Numbers -1014806,1014808Item Description -Two Terminal Micro Switch forAccelerator Speed Switch on1981 to 1984 Club Car and gascomponent box on 1984 andnewer as well as the Forwardand Reverse Switch ongasloline Club Cars from 1984to 1998

Brush Set,Starter/GeneratorPrice: $23.45Part Number: BR110

OEM Part Numbers - HD30422-69, 30443-77, CC1013023, 1014699,1018693-01, EZ 16888-G1,26658-G01, YA J10-81111-10,J38-81111-10, JF2-81111-00,JF7-81111-00, CG1-801090Item Description -Brush Set for Starter/Generatoron 1967 and newer Harley with



Item Description -50 amp Circuit Breaker forLester battery charger on HarleyDavidson, E-Z-GO before TotalCharge, and Club Car, also will

CLUB CAR ELECTRICAL & STARTER/GEN

CLUB CAR ELECTRICAL & STARTER/GEN 33

Hitachi style Starter/Generator,Club Car 1984 to 1996, E-Z-GO1980 to 1993, Yamaha 1978and newer G1, G2, G8, G9,G11, G14, G16, G20, G21, G22,Hyundai 1991 and newer. 1"long by 17/32" wide by 7/32"thick

replace 74857-67 diode onHarley Davidson speed controlon master drive control systemon 1969 to 1970 model DEC,1967 to 1971 model DE, and1979 to 1982 model MGIV, tworequired for master drive system.

Micro SwitchPrice: $8.75Part Number: SW202OEM Part Numbers -EZ12374-G1, 13141-G1, CC1011439, OT A-54700Item Description -Plunger Style Micro Switch forLights with three terminals for1971 to 1982 E-Z-GO gas andelectric, Club Car 1981 andnewer with lights, also Otis

Resistor for SolenoidPrice: $4.35Part Number: SO210OEM Part Numbers - EZ21764-G1, CC 1014947, CO70592-87Item Description -Resistor that goes across largeposts on 1989 and newerE-Z-GO with electronic solidstate speed controller. Not foruse with 1995 to 1999 DCS(Drive Control System)carts.Also for 1990 and newer ClubCar, Columbia Par Car/Harley,and Cushman with Curtis solidstate speed control and 1989and newer Yamaha with Curtissolid state speed control. Alsoused when converting olderresistor carts to modern motorspeed control systems, 250 ohmwith two crimp terminal ends,OEM Quality

Brush HolderPrice: $32.17Part Number: BR111OEM Part Numbers - HD30351-77, CC 1013011, EZ16887-G1, YA JF2-81119-00 ,HY GG1-801080Item Description -Starter Generator Brush Holderwith Brushes and Springs for1972 to 1995 Harley Davidsonwith Hitachi Starter Generatorsonly, Also 1984 to 1995 ClubCar, and 1978 to 1993 E-Z-GO,and 1985 to 2007 Yamaha G2,G3, G5, G8, G9, G11, G14,G16, G20, G21, and G22, alsoHyundai with HitachiStarter/Generator

Drive End CoverPrice: $28.08Part Number: EL104OEM Part Numbers - HD30111-77, EZ 16884-G1,16885-G1, 16886-G1, CC1012993 1012999, 1018764-02,YA J10-81165-00,J10-81165-10, J10-81166-10,HY GG1-801060Item Description -Starter/Generator Front Coverfor 1977 and newerColumbia/Harley-Davidson,1978 to 1993 E-Z-G 2 cycle,1985 to 1995 Club Car, also G1Yamaha from 1979 to 1989 andHyundai all with Hitachi styleStater/Generator only), DirectReplacement, OEM Quality.

ArmaturePrice: $179.21Part Number: EL201OEM Part Numbers - EZ16875-G1, 26870-G01, HD

Field CoilsPrice: $99.95Part Number: EL202OEM Part Numbers - EZ16880-G1, 25533-G02,



30083-5, 30083-69E, 30860-77,CC 1013004, YA J10-81150-10,HY GG1-801010Item Description -Armature for Hitachi StyleStarter Generator for 1978 to1994 E-Z-GO Pre MedalistMarathon model with 2 cycleengine, Also 1972 to 1995Columbia /Harley Davidson with2 cycle engine, and 1984 to1995 Club Car, as well as 1979to 2002 Yamaha models G1,G2, G8, G9, G11, G14, andG16, and 1991 and newerHyundai, same quality as OEM

25533-G03, 26875-G01 , HD30210-77, CC 1013004Item Description -Armature for Hitachi StyleStarter Generator for 1978 to1994 Pre Medalist E-Z-GOMarathon model with 2 cycleengine, Also 1972 to 1995Columbia /Harley Davidson with2 cycle engine, and 1984 to1995 Club Car, same quality asOEM

Voltage ReducerPrice: $198.87Part Number: EL260OEM Part Numbers -16511-G1,16874-G1Item Description -Voltage Reducer for all cartswith 24, 36, or 48 volt systems.Converts these voltages downto 12 volts for running lights,radios and other 12 voltaccessories. Has a high ampoutput of 25 amps peak.Includes heat shrink andmounting hardware

Drive End St/GenBearing & Int. GearPrice: $8.49Part Number: BE142OEM Part Numbers - 6303DU,HD 30151-69, 30153-77, EZ16877-G1, 23521-G1,26872-G01, CC 1013001, YA93306-30317, J10-81158-10,HY GG1-801180Item Description -Drive End Bearing forStarter/Generator on 1972 to1995 Harley, E-Z-GO 1978 to1993 2 cycle and 1991 andnewer 4 cycle, also IntermediateGear Bearing on 1988 andnewer E-Z-GO electricTransaxle, also Drive EndBearing on Club Car, and 1978and newer Yamaha G1, G2, G8,G9, G11, G14, G16, G19, G20,G21, and G22, and Hyundai.Measures .67" I.D. by 1.25"O.D. by .55" wide

Commutator EndBearingPrice: $6.44Part Number: BE141OEM Part Numbers - 6202V,HD 30149-67, 30154-77, EZ16876-G1, 26871-G01, CC1013005, YA 93306-20226,J10-81157-10, ME 300406, HYGG1-801170Item Description -Commutator End Bearing forStarter/Generator on 1972 to1995 Harley, E-Z-GO 1978 to1993 2 cycle and 1991 andnewer 4 cycle, also Club Car,also 1978 and newer Yamaha

Charging FusePrice: $11.70Part Number: bt415OEM Part Numbers -1014516Item Description -Charging Fuse for 1985 to 2002Club Car, includes fuse, fuseholder and lens, 80 amp rating



G1, G2, G8, G9, G11, G14,G16, G19, G20, G21, and G22,and Melex, and Hyundai.Measures .59" I.D. by 1.38"O.D. by .43" wide

Starter / GeneratorPrice: $274.37Part Number: EL100OEM Part Numbers - HD30083-69A, 30083-69B,30083-69C, 30093-69D,30083-69E, 30083-95, CC1012316, 1018294-01Item Description -Columbia/Harley-Davidson,1967 to present. Also for ClubCar model DS from 1984 to1996-1/2. Replaces Hitachi andBosch style units.


OEM Part Numbers - TD75-235-20Item Description -5-3/4" long 6 gauge BlackBattery Cable with 5/16" eyelet


OEM Part Numbers - YAJR1-H2149-00, JR1-H2149-01,HY GB1-802012, GB1-803012Item Description -7-1/2" long 6 gauge BlackBattery Cable with 5/16" eyelet


OEM Part Numbers - CU881995, 883077, DA 65723, LE262605, ME 300615, NO 565,ND A06BLK0090DD,A2568B62A09, PA 3029, YAJ14-82127-00, J14-82148-00,J56-H1890-00, J56-H2127-00,JG6-H1890-00, JG6-H1890-01Item Description -9" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - CC 7296,HD 70199-68C, CU 882661,883078, EZ 11893-G1,14611-G1, 30277-G1, JA557261, LE 626605, ME300615, NO 565, PA 3029Item Description -9" long 6 gauge Red BatteryCable with 5/16" eyelet




OEM Part Numbers -Item Description -10" long 6 gauge Red BatteryCable with 5/16" eyelet


OEM Part Numbers - CC 7622,1010958, HD 70108-85, CU882947, HY GB1-802014GB1-802015, LE 621492,625144, ME 300611, NO561-12N, ND A06BLK0120BD,



PA 3019Item Description -12" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - CC 7295,CU 835340, EZ 11888-G2,14610-G1, LE 621492, 625144,ME 300611, NO 561-12P, PA3019Item Description -12" long 6 gauge Red BatteryCable with 5/16" eyelet


OEM Part Numbers - CU814417, 882374, 882948,882954, 883186, NO 561-14N,YA JR1-H2127-00,JR1-H2127-01Item Description -14" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - CC 7263,DA 65706, HY GB1-802013, LE624779, ME 300610, NO561-16N, ND A06BLK0160DD,A2905B50A11Item Description -16" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - CU884116, EZ 11885-G4, JA557259, LE 624779, ME300610, NO 561-16PItem Description -16" long 6 gauge Red BatteryCable with 5/16" eyelet


OEM Part Numbers - CC 7294,8540, HY GB1-802034, LE624414, NO 561-18N, PA 3018Item Description -18" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - CC 7293,CU 835341, LE 624414, NO561-18P, PA 3018Item Description -18" long 6 gauge Red BatteryCable with 5/16" eyelet




OEM Part Numbers - NO561-20P, ND A2905B50A14Item Description -21" long 6 gauge Red BatteryCable with 5/16" eyelet

Battery Cable SetPrice: $16.58Part Number: EL930

OEM Part Numbers - CC1010958Item Description -Battery Cable Set for 1985 to1994 36 Volt Yamaha G2, G8,


OEM Part Numbers - NDA2905B50A05, A2905B50A15,A2905B50A19Item Description -23" long 6 gauge Black Battery



and G9, Also for 1981 andnewer Club Car model DS.Includes five 12" long six gaugecables

Cable with 5/16" eyelet


OEM Part Numbers - EZ11883-G1, 11884-G1,11885-G2 11888-G3,23540-G1, 11888-G3Item Description -23" long 6 gauge Red BatteryCable with 5/16" eyelet



Battery Cably, Red 24''Price: $7.80Part Number: EL959

OEM Part Numbers - CU887854, NO 561-24PItem Description -24" long 6 gauge Red BatteryCable with 5/16" eyelet


OEM Part Numbers - DA 65713,PA 3033Item Description -26" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - EZ14632-G1, PA 3033Item Description -26" long 6 gauge Red BatteryCable with 5/16" eyelet


OEM Part Numbers - EZ14632-G1, PA 3033Item Description -28" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - EZ11892-G4Item Description -28" long 6 gauge Red BatteryCable with 5/16" eyelet


OEM Part Numbers - CU886640, NO 561-30NItem Description -30" long 6 gauge Black BatteryCable with 5/16" eyelet


OEM Part Numbers - CU886645, DA 65875, EZ11891-G4, 11892-G1, NO561-30PItem Description -30" long 6 gauge Red BatteryCable with 5/16" eyelet


OEM Part Numbers - LE621857, NO 561-32NItem Description -32" long 6 gauge Black BatteryCable with 5/16" eyelet





OEM Part Numbers - EZ11889-G1, 11890-G1, LE621857, CC 1019028-01Item Description -32" long 6 gauge Red BatteryCable with 5/16" eyelet


Battery Cable, Red42-1/2''Price: $17.55Part Number: EL971

OEM Part Numbers - CU881644Item Description -42-1/2" long 6 gauge RedBattery Cable with 5/16" Eyeletson both ends, fits Cushman andmany others

Woodruff Key, driveFlange & St/GenPrice: $3.22Part Number: CL142

OEM Part Numbers - HD 11206,CC 1013003Item Description - PrimaryClutch Drive Flange WoodruffKey for 1977 to 1981 HarleyDavidson gas models D, DC,and D4, Also 1984 and newerClub Car Starter GeneratorPulley. Direct replacement,same quality as OEM. Usedwith front drive flange numberCL127. Measures: 3/16" thick by5/8" long

Battery Cable SetPrice: $18.25Part Number: EL930B

OEM Part Numbers - CC0107957-01Item Description -Battery Cable Set for 1995 andnewer 48 Volt Club Car modelDS. Includes five 14" long sixgauge cables

Give us a call!1 (360) 385-4868





ENGINE (GAS)MufflerPrice: $164.49Part Number: EN430OEM Part Numbers -1013661Item Description -Heavy Duty ReplacementMuffler for 1984 to 1991 ClubCar gas models

Head GasketPrice: $18.92Part Number: EN412OEM Part Numbers - 1012511Item Description -Head Gasket for 1984 to 1991Club Car, 7 holes

Engine Rebuild KitPrice: $399.35Part Number: EN400OEM Part Numbers -1013474-25Item Description -Engine Rebuild Kit for 1984 to1985 Club Car, comes with.25mm over piston, rings, pistonpin with retainers, valves, rollerbearings, connecting rod,crankshaft assembly withstraight cut gear on fan side andgasket set

Engine Rebuild KitPrice: $399.35Part Number: EN401OEM Part Numbers -1013474-50Item Description -Engine Rebuild Kit for 1984 to1985 Club Car, comes with.50mm over piston, rings, pistonpin with retainers, valves,bearings, connecting rod,crankshft assembly and gasketset

Engine Rebuild KitPrice: $399.35Part Number: EN402OEM Part Numbers -1013474B-25Item Description -Engine Rebuild Kit for 1986 to1991 Club Car with 341ccengine, comes with .25mm overpiston, rings, piston pin withretainers, valves, all seven rollerbearings, connecting rod,crankshaft assembly, seals andgasket set

Engine Rebuild KitPrice: $399.35Part Number: EN403OEM Part Numbers -1013474B-50Item Description -Engine Rebuild Kit for 1986 to1991 Club Car, comes with.50mm over piston, rings, pistonpin with retainers, valves, allseven roller bearings,connecting rod, crankshaftassembly, seals and gasket set

Piston AssemblyPrice: $53.24Part Number: EN404OEM Part Numbers - 1012515Item Description -Piston Assembly for 1984 to1991 Club Car, comes withstandard aluminum piston,rings, and piston pin withretainers

Piston AssemblyPrice: $53.24Part Number: EN405OEM Part Numbers - 1012958Item Description -Piston Assembly for 1984 to1991 Club Car, comes with.25mm over aluminum piston,rings, and piston pin withretainers for use with cylinderbored to 80.25mm (3.16")

Piston AssemblyPrice: $53.24Part Number: EN406OEM Part Numbers - 1012959Item Description -Piston Assembly for 1984 to1991 Club Car, comes with.50mm over aluminum piston,

Piston Ring SetPrice: $27.59Part Number: EN407OEM Part Numbers - 1012516Item Description -Standard Piston Ring Set for1984 to 1991 Club Car

CLUB CAR ENGINE (GAS)

CLUB CAR ENGINE (GAS) 40

rings, and piston pin withretainers for use with cylinderbored to 80.50mm (3.17")

Piston Ring SetPrice: $27.59Part Number: EN408OEM Part Numbers - 1012960Item Description -.25mm over Piston Ring Set for1984 to 1991 Club Car

Piston Ring SetPrice: $27.59Part Number: EN409OEM Part Numbers - 1012961Item Description -.50mm over Piston Ring Set for1984 to 1991 Club Car

Crankcase GasketPrice: $4.39Part Number: EN410OEM Part Numbers - 1012519Item Description -Crankcase Gasket for 1984 to1991 Club Car, die cut with 13holes

Cylinder Base GasketPrice: $5.85Part Number: EN411OEM Part Numbers - 1012960Item Description -.25mm over Piston Ring Set for1984 to 1991 Club Car

Transmission CaseGasketPrice: $10.15Part Number: EN413OEM Part Numbers - 10125717Item Description -Transmission Case Gasket for1984 to 1991 Club Car, 11 holes

Pump Cover GasketPrice: $1.45Part Number: EN414OEM Part Numbers - 1013952Item Description -Pump Cover Gasket for 1984 to1991 Club Car, 1-25/32"between holes

Tappet Cover GasketPrice: $1.85Part Number: EN415OEM Part Numbers - 1012846Item Description -Tappet Cover Gasket for 1984to 1991 Club Car, 3-3/32" longby 1-25/32" wide by 3/32" thick

Balancer GearPrice: $40.17Part Number: EN416OEM Part Numbers - 1012868Item Description -Balancer Gear for 1984 to 1985Club Car, thin gear with straightteeth

Balancer GearPrice: $40.17Part Number: EN417OEM Part Numbers - 1013990Item Description -Balancer Gear for 1986 to 1991Club Car, thin gear with helicalteeth

Crankshaft GearPrice: $50.12Part Number: EN418OEM Part Numbers - 1012872Item Description -Crankshaft Gear for 1984 to1991 Club Car, wide gear withhelical teeth

Engine MountPrice: $2.25Part Number: EN419OEM Part Numbers - 1016810Item Description -Engine Mount for 1984 andnewer Club Car, moldedpolyurethane to factoryspecifications

Muffler GasketPrice: $4.19Part Number: EN431OEM Part Numbers - 1012510,1015450Item Description -Muffler Gasket for 1984 to 1991Club Car, goes between mufflerand header pipe, 2-5/16"between holes



Crankcase SealPrice: $5.56Part Number: BE412

OEM Part Numbers - 1012524Item Description -Crankcase Oil Seal for bothClutch and Flywheel Side on1984 to 1991 Club Car modelDS, Measures 1.96" (50mm)O.D. by 1.18" (30mm) I.D. by.31" (8mm) wide


OEM Part Numbers - HD 9031,30150-67, 90004-90, CC1011290, 1012877, EZ16918-G1, 23520-G1,27630-G13, JA 343667, TD80-201-00, TO 251-6, CU812009, 824753, 832498, YA93306-20304, 93306-20309,93306-20310, 93306-20314,93306-20316, 93306-20324,93306-20331, 93306-20345,903306-203X1,J56-H1857-00-00, HYGB1-801003Item Description -Front Inner Wheel Bearing for1983 and newer HarleyDavidson, also both sides ofBalancer Shaft on 1995 andnewer 4 cycle, Club Car gasbalancer shaft clutch side,camshaft flywheel from 1984 to1991 and electric motor brushend from 1981 and newer(except IQ system), E-Z-GOelectric motor brush end on1980 to 1996, also Jacobsen,Taylor Dunn, Toro, Cushman,also Yamaha front outer wheelbearing for G1 from 1978 to1981 and electric motor brushend on 1990 and newer G8, G9,G14, G16, G19 and G20, AlsoHyundai. Dimensions: .66"(16.8mm) I.D. by 1.57"(39.9mm) O.D. by .47"(11.9mm) W.

Crankcase BearingPrice: $10.43Part Number: BE201OEM Part Numbers -EZ14521-G1, 24504-G1, CC1019281-01, YA 93306-20627,HY 86W-000030, Kohler231625Item Description -Crankcase Bearing for 1976 to1993 E-Z-GO, 2 cycle engine,Clutch side Cam Bearing for1984 to 1991 Club Car with 341cc 4-cycle engine, Fan SideCrankshaft Bearing for 1978 to1989 Yamaha G1, also 1991

Crankshaft BearingPrice: $16.19Part Number: BE411OEM Part Numbers - CC1012867, 1016565, YA93306-20610, 93306-20612,93306-20633, 93306-30610,93306-30621, 93306-30622,93306-30630Item Description -Crankshaft Bearing for 1984 to1991 Club Car with 341 ccEngine and Clutch SideCrankshaft Bearing for 1978 to1996 Yamaha models G1, G2,G8, G9 and G14



and newer Hyundai CrankshahftBearing and Kohler CrankshaftBearing. Dimensions: 2.450"OD, 1.175" ID, .630 width



FUELAir FilterPrice: $7.15Part Number: FU409OEM Part Numbers -1015426Item Description -Panel Air Filter Element for1992 and newer Club Car modelDS carts with OHV 4 cycleengine

Throttle CablePrice: $18.04Part Number: FU400OEM Part Numbers - 1012443,1013158, 1013163Item Description -Throttle Cable for 1984 to 1991Club Car, 10-1/4" housinglength, 16-3/4" cable length

CarburettorPrice: $256.45Part Number: FU401OEM Part Numbers - 1012508,1014541Item Description -Carburetor for 1984 to 1991Club Car, includes linkage rodand all mounting gaskets

Carburetor KitPrice: $50.31Part Number: FU402OEM Part Numbers - 1012974Item Description -Carburetor Repair Kit for 1984to 1991 Club Car, includes floatbowl O-ring, manifold gasket,pilot jet, main jet, pilot screwand spring, idle stop screw andspring, main nozzle, needlevalve gasket, float bowlretaining nut and gasket

Carb GasketPrice: $1.35Part Number: FU403OEM Part Numbers - 1012507Item Description -Caburetor Base Gasket for 1984to 1991 Club Car with 341ccengine, measures 1-9/16"between mounting stud holecenters

Carburetor Base GasketPrice: $1.35Part Number: FU404OEM Part Numbers - 1012509Item Description -Caburetor Base Gasket for 1984to 1991 Club Car with 341ccengine, measures 1-25/32"between mounting stud holecenters

Fuel PumpPrice: $58.11Part Number: FU405OEM Part Numbers - 1012507Item Description -Mikuni Fuel Pump for 1987 to2005 Club Car DS, Carryall, andPrecedent

Fuel Pump KitPrice: $36.47Part Number: FU406OEM Part Numbers - 1013762Item Description -Fuel Pump Repair Kit for 1984to 1987 Club Car with rounddiaphram, includes 3 bodygaskets, neoprene and plasticdiaphram and valve assembly

Fuel Pump KitPrice: $27.62Part Number: FU407OEM Part Numbers - CC1014524, EZ fuel pump #s5146, 2147, 5148Item Description -Fuel Pump repair Kit for 1988and newer Club Car with squarediaphragm, E-Z-GO, 1990-1/2and newer, and Yamaha 1990and newer G8 through G22,includes gaskets and

Air Filter ElementPrice: $7.61Part Number: FU104OEM Part Numbers -HD29132-71, EZ 29131-88, CC1013379Item Description -Harley-Davidson 1967 topresent models D, DC, D4. 2cycle and E-Z-GO 1976 to 19942 cycle, Club Car 1984 to 1991.Layered paper type elementwith an inner and outer wire

CLUB CAR FUEL

CLUB CAR FUEL 44

diaphragms mesh encasement and sealedend caps. 6-1/4" high, 4-1/4"diameter. OEM quality

Fuel FilterPrice: $3.45Part Number: FU100OEM Part Numbers - HD62489-85, EZ 23013-G1,JN6-F4560-00Item Description -Fits Harley-Davidson andE-Z-GO 1971 to 1993, YamahaG14, G16, G20, and G22 &Most all golf carts, In line"arrow" style plastic filter. 1/4"

Fuel Line, 4 FeetPrice: $9.27Part Number: FU148OEM Part Numbers -62526-85,62530-85, 62528-85,62534-84,63581-74Item Description -Columbia/Harley-Davidson,1963 to present. 1/4" I.D. DirectReplacement. OEM Quality. Fitsmany other carts as well.

Gas CapPrice: $8.09Part Number: FU152OEM Part Numbers -HD61252-80, 61254-89, CC1012306, HY GGI-104170Item Description -Direct Replacement Gas Capfor 1975 to 1995 HarleyDavidson and Columbia ParCar, also 1984 to 1991 ClubCar.

Clamp, Fuel LinePrice: $0.85Part Number: FU149OEM Part Numbers -HD 9993,CC 1012294, 1013134-02, EZ11391-G1, 18292-G1, JA556074, 594077Item Description -Hose Clamp for 1963 and newerColumbia/Harley-Davidson,1984 to 1991 Club Car, Allyears of E-Z-GO, plusJacobsen. For 1/4" & 5/16" fuelline.

Fuel Filter, 1/4Price: $2.55Part Number: FU106OEM Part Numbers -HD62350-63, CC 1012342, EZ12902-G1, YA 1FK-24560-01Item Description -Harley-Davidson, Club Car,E-Z-GO, Yamaha G1 2 cycle,fits most golf cars that use 1/4"I.D. tubing. 1/4" nipple.

Give us a call!1 (360) 385-4868



CLUB CAR FUEL

CLUB CAR FUEL 45

IGNITIONKeyPrice: $1.79Part Number: IG405OEM Part Numbers - 1012505Item Description -Ignition Key for 1983-1/2 andnewer Club Car models DS andPrecedent.

KeyPrice: $1.79Part Number: IG404OEM Part Numbers - 8205,1014173Item Description -Ignition Key for 1976 to1983-1/2 Club Car electric,NOTE: Price for One Key Only

Exciting CoilPrice: $88.63Part Number: IG410OEM Part Numbers -1012521Item Description -Exciting Coil for 1984 to 1991Cliub Car, has three lead wires,black, red, and white plus threeprong triangle shaped bulletplug, two male and one female

Ignition CoilPrice: $51.78Part Number: IG413OEM Part Numbers -1016492Item Description -Ignition Coil for 1992 to 1996Club Car, has one male spadeterminal

Ignition Coil & RPMLimiterPrice: $199.95Part Number: IG411OEM Part Numbers -1012520Item Description -Ignition Coil with built in RPMLimiter for 1984 to 1989 ClubCar, has three lead wires(brown, red, white), andtriangular plug connector withtwo female and one male bullettype connector, and one singleblack lead with insulated femalebullet type connector

Ignition CoilPrice: $96.53Part Number: IG412OEM Part Numbers -1015925Item Description -Ignition Coil for 1990 to 1991Club Car, has two lead wiresand connector plug with onemale and one female bullet typeconnector

Ignition Coil IgnitorPrice: $72.45Part Number: IG414OEM Part Numbers -1016491Item Description -Ignition Coil Ignitor for 1992 to1996 Club Car, has extensionwire with male and femalespade connectors, wire nut andmounting screw

Ignition CoilPrice: $86.68Part Number: IG415OEM Part Numbers-1019092-01Item Description -Ignition Coil and Ignitor for 1997and newer Club Car DS andPrecedent, has one male spadeterminal

Ignition SwitchPrice: $20.87Part Number: IG400

OEM Part Numbers -8204Item Description -Ignition Switch for 1976 to1983-1/2 Club Car, comes with2 keys


OEM Part Numbers -1012531Item Description -Ignition Switch for 1981 to 1995Club Car Electric models,comes with 2 keys

CLUB CAR IGNITION

CLUB CAR IGNITION 46


OEM Part Numbers-1018163-01Item Description -Ignition Switch Only for 1996and newer Club Car model DS.

IG407Price: $29.25Part Number: IG407

OEM Part Numbers-1018262-01Item Description -Ignition Switch Only for 199 andnewer Club Car 48 Volt modelDS.


OEM Part Numbers-1025086-01Item Description -Ignition Switch Only for 2004and newer Club Car ElectricPrecedent model.


OEM Part Numbers -1012415Item Description -Ignition Switch for 1983-1/2 to1995 Club Car Gas models,comes with 2 keys

Key Switch CapPrice: $3.35Part Number: IG417

OEM Part Numbers-1018345-02Item Description -Ignition Switch Plastic Cap for1996 and newer Club Car DSand Precedent models.

Key Switch NutPrice: $2.98Part Number: IG418

OEM Part Numbers-1018307-01Item Description -Nut for Plastic Ignition Switch1996 and newer Club Carmodels DS and Precedent

Ignition Switch WasherPrice: $3.15Part Number: IG419

OEM Part Numbers-1018511-01Item Description -Washer for Plastic IgnitionSwitch for 1996 and newer ClubCar models DS and Precedent

Ignition Switch, MixedKeysPrice: $16.25Part Number: IG207

OEM Part Numbers -OTA-46113Item Description -Universal Ignition Switch withmixed key codes, two terminalon/off switch with 2 keys, manyapplications

CLUB CAR IGNITION

CLUB CAR IGNITION 47

INSTRUMENTSState of Charge MeterPrice: $37.05Part Number: IN100

OEM Part Numbers -Item Description -36 Volt Analog State of ChargeMeter, Square Face, For All 36Volt Carts

AmmeterPrice: $21.94Part Number: BT110

OEM Part Numbers -HD66506-69, CC 1012097,1012106, L2000Item Description -Square Face 30 Amp Ammeterfor Lester Charger used onHarley Davidson, Club Car, andothers for Lester models 6720,8600, 8650, 8714, 8946, 9027,9028, 9032, 9611, 13165,includes insulated terminals,busbar, hardware andinstruction sheet, measures2-1/4" by 2-1/4"

State of Charge MeterPrice: $25.35Part Number: IN101

OEM Part Numbers -Item Description -36 Volt Analog State of ChargeMeter, Round Face, For all 36Volt Carts

State of Charge MeterPrice: $96.53Part Number: IN102

OEM Part Numbers -Item Description -36 Volt Curtis LED State ofCharge Meter, displays reservewarning and has an emptyalarm, 3 1/6" long by 2 1/8"wide, For All 36 Volt Carts.

CLUB CAR INSTRUMENTS

CLUB CAR INSTRUMENTS 48

MANUALS & PUBLICATIONSService ManualPrice: $22.95Part Number: PU400OEM Part Numbers -8240Item Description -Maintenance and OperationManual for 1975 to 1979 ElectricClub Car, inlcudes wiringdiagram

Service ManualPrice: $27.50Part Number: PU401OEM Part Numbers -1011633Item Description -Service Manual for 1981 to1983-1/2 Electric Club Car

Parts ManualPrice: $24.50Part Number: PU402OEM Part Numbers -8958Item Description -Parts Manual for 1976 to 1980Electric Club Car

Parts ManualPrice: $45.45Part Number: PU403OEM Part Numbers -1013165Item Description -Parts Manual for 1981 to 1991Electric Club Car model DS

Service ManualPrice: $98.40Part Number: PU404OEM Part Numbers -1012799Item Description -Service Manual for 1984 to1985 gas Club Car model DS

Service ManualPrice: $106.05Part Number: PU405OEM Part Numbers -1014187Item Description -Srevice Manual for 1986 to1991 Electric Club Car modelDS

Service ManualPrice: $95.97Part Number: PU406OEM Part Numbers -1015055Item Description -Service Manual for 1986 to1991 Gas Club Car model DS

Parts ManualPrice: $45.45Part Number: PU408OEM Part Numbers -1014475Item Description -Parts Manual for 1986 to 1991Gas Club Car model DS

Parts ManualPrice: $67.43Part Number: PU409OEM Part Numbers-1017701-02Item Description -Parts Manual for 1992 to 1994Gas and Electric Club Carmodel DS

Service ManualPrice: $104.92Part Number: PU410OEM Part Numbers-1017701-01Item Description -Srevice Manual for 1992 to1994 Gas and Electric Club Carmodel DS



CLUB CAR MANUALS & PUBLICATIONS

CLUB CAR MANUALS & PUBLICATIONS 49

MOTORS (ELECTRIC)Brush, Traction MotorSetPrice: $45.24Part Number: BR103OEM Part Numbers - HD82918-79, CC 1011332,1011424, YA J14-81811-10,Item Description -Brush Set for late 1979 to 1982Harley Davidson model DE3with Hitachi Motor only, alsoClub Car 1980 to 1984, andYamaha G1 and G2 . (set of 4),length 1-1/8"long, 11/16" wide,5/8"deep.

16 Spine MotorPrice: $658.45Part Number: MT402OEM Part Numbers - EZ73124-G04, CC 7260, 7448, PA3365, 2227, GE 5BC48JB719,5BC48JB722, 5BC48JB524,5BC48JB558B, 5BC48JB691,Hitachi MT320-07Item Description -16 External Spine, 36 Volt 2.90HP, 2475 RPM ReplacementMotor for 1976 to 1983 Club Carwith Terrill differential, also 1969and newer Pargo with Terrilldifferential with disc brake ondifferential, in addition 1960sE-Z-GO with 16 Spline Motor.NOTE: This motor has slightlymore horsepower than theoriginal motor.

High Speed MotorPrice: $674.32Part Number: MT403OEM Part Numbers - 7260,7448Item Description -High Speed 16 External Spine3850 RPM, 36 Volt High SpeedReplacement Motor for 1976 to1983 Club Car with Terrilldifferential, also 1969 andnewer Pargo with Terrilldifferential with disc brake ondifferential, in addition 1960sE-Z-GO with 16 Spline Motor,on 36 volts it will increase speedfrom 12 mph to 16-17.5 mph. Ifrun on 48 volts it will increasespeed to 20-22 mph. NOTE:You must either retrofit to 400amp controller and 200 ampsolenoid and heavier wires orupgrade all solenoids to 200amp units and install heavierwiring

10 Spline MotorPrice: $397.85Part Number: MT405OEM Part Numbers - CC1012643, 1012653, 1014678,1017728-01, 1017728-02,1018134-01, 1018134-02,1022374-01, YA JG6-H1890-00,JG6-H1890-01Item Description -10 Spine 36 Volt UpgradeReplacement Motor for 1984and newer Club Car and andYamaha 1989 to 1993-1/2 G1,G2, G8, and G9 with Grazianoor Kawasaki Differentials. 3.5HP @ 3000 RPMs. NOTE: Notfor use with Club CarPowerDrive Plus systems

Brush SetPrice: $37.44Part Number: BR107OEM Part Numbers - HD70491-73, 82842-86, CC 7363,EZ 15445-G1, 15634-G1, PA2227-3, TD 70-105-00, NR20753, DA 56224Item Description -Brush Set for GE Motors with

Motor CouplerPrice: $43.68Part Number: MT215OEM Part Numbers -26926-G01Item Description -10 Spline Motor Coupler forrepairing stripped splines onE-Z-GO 1971 to 1985 and ClubCar 1981 to 1985

CLUB CAR MOTORS (ELECTRIC)

CLUB CAR MOTORS (ELECTRIC) 50

cable lead crossovers used onHarley Davidson from 1986 to1990, Club Car 1981 to 1985,E-Z-GO, Pargo, Taylor Dunn,Nordskog and Davis.(set of 4),length 1-7/16" long by 5/8" wideby 1/2" thick. NOTE: similar toBR101 except this brush has agroove in the top for the brushspring

Brush SetPrice: $40.37Part Number: BR102OEM Part Numbers - HD70491-63, 72367-72, CC 7363,8089, 8785, EZ 50278-G1,72368-G01, CU 807329,824251, 882960, TD 70-100-00,ME 500117, PA 3365-3, OTA-20663, WE 20663,A2623A54H02, A2623A54H03Item Description -Brush set for GE Motors usedon 1963 to 1971 HarleyDavidson models DE, DEF,DEC and 1972 to 1975 modelsDE and DE4, Club Car pre1980, E-Z-GO 1965 to 1972,also Cushman, Taylor Dunn,Melex pre 1985 models 102,202, 112, 212, 152, 252, andearly 412 with band brake onmotor, also Pargo as well asWestinghouse Motors used on1965 to 1976 WestinghouseMarketeer models 436, 436G,437 and 437A, and 529 Chariot,also Otis, Nordskog and othersusing Westinghouse motors (setof 4), length 1-5/8" long, 5/8"wide, 1/2" deep with springhook. NOTE: Used with both GEand Westinghouse motors

Brush SetPrice: $53.24Part Number: BR101OEM Part Numbers - HD70491-73, CC 7363, EZ15634-G1, 51318-G1, CU882960, 883663, TD 70-101-00,ND 20753, PA 2227-3, NOM-14, OT A-56224Item Description -Brush Set for GE Motors usedon Harley Davidson model DE3from 1977 to 1978 and modelDE40 from 1976 to 1978, ClubCar 1976 to 1980, E-Z-GO 1973to 1979, HMK Marketeer models438 and 439, Cushman, TaylorDunn, Nordskog, Pargo, Nolandand Otis .(set of 4), length1-3/16" long by 5/8" wide by 1/2"thick.

Brush AssemblyPrice: $58.11Part Number: BR100OEM Part Numbers - HD83283-86, CC 1011410,1011282, ME 520108, CU886026, TD 70-104-00, LE5561-200, ND 20953, HYGB1-801062Item Description -Brush Assemblies for GEmotors used on 1986 to 1990Harley-Davidson, Club Car 1980to 1993 36 volt, Melex 1985 andnewer models 412, 512, and

Brush HolderPrice: $64.47Part Number: BR205OEM Part Numbers -EZ16916-G1, 16916-G2, CC1011284, HD 83284-86, LE5561-1Item Description -Brush Holder with Springs for1980 to 1992 E-Z-GO with G.E.Motor, Club Car 1984 to 199336 volt, Columbia Harley 1986to 1990, and Legend



625, Cushman, Taylor Dunn,Legend, Nordskog and Hyundai.length 1-7/16" long, 5/8" wide,1/2"deep. Set includes twoassemblies.

Brush SpringPrice: $5.27Part Number: BR105OEM Part Numbers - HD72383-66, EZ 50280-G1, CU814289, TD 85-401-00, ME500115, ND 20433, PA 3365-5Item Description -Pull Type Brush Spring for GEMotors used on 1963 to 1971Harley Davidson models DE,DEF, DEC and 1972 to 1973models DE and DE4, alsoE-Z-GO, Club Car pre 1980,Cushman, Taylor Dunn, Melexpre 1985 models 102, 202, 112,212, 152, 252, and early 412with band brake on motor, AlsoWestinghouse Marketeermodels 436, 436G, 437 and437A and 529 Chariot, andNordskog, and Pargo .

Brush SpringPrice: $2.40Part Number: BR104OEM Part Numbers - HD83287-86, CC 1011411, EZ15446-G1, CU 824754, TD85-412-00, DA 56225, LE2227-5, NO M-12, ND 10556,OT A-56225, PA 2227-5Item Description -Brush Spring for G.E. Motorused byColumbia/Harley-Davidson,Club Car 1984 and newer,E-Z-GO new style G.E. motor,HMK Marketeer models 438 and439, Melex 1985 and newermodels 412, 512, and 625, alsoCushman motor brush springand speed board brush spring,Taylor Dunn, Davis, Legend,Noland, Nordskog, Otis, Pargo,and Yamaha G8, G9, G14, G16.

Brush SpringPrice: $5.76Part Number: BR106OEM Part Numbers - HD82919-79, CC 1011420, YAJ14-81813-10Item Description -Brush Spring for late 1979 to1982 Harley Davidson modelDE3 and MGIV, with HitachiMotor only, also Club Car 1980to 1984 and Yamaha G1 andG2 with Hitachi Motor

Repair Stud, Screw OnPrice: $5.99Part Number: MT111OEM Part Numbers -Item Description -Screw On Motor Repair Stud forrepairing broken field coil studson GE Motors, 5/16" by 18coarse thread

Fiber WasherPrice: $2.45Part Number: MT112OEM Part Numbers -HD83260-75, 83289-86, CU823015, 824710, EZ 15442-G1,50309-G1, 51330-G1, DA56236, NO M-13, PA 2227-11,ND 70621, 70771Item Description -Round Fiber Washer for oldstyle GE Motors used on HarleyDavidson, Cushman, E-Z-GO,Davis, Noland, Pargo, Nordskogand others, has .475 hole, goeson inside where stud field stud

Fiber WasherPrice: $2.85Part Number: MT113OEM Part Numbers -HD83256-75, 83288-86, CU814316, 824718, EZ 15438-G1,50289-G1, 51327-G1, DA56233, NO M-6, LE 2227-38,ND 70611, PA 2227-13,3365-13Item Description -Round Fiber Washer for oldstyle GE Motors used on HarleyDavidson, Club Car, Cushman,E-Z-GO, Davis, Noland, Otis,Legend, Taylor Dunn and Pargo



or brush stud goes through thebrush housing

and others, has .330 hole, goeson outside where field stud orbrush stud goes through thebrush housing


OEM Part Numbers - HD 9031,30150-67, 90004-90, CC1011290, 1012877, EZ16918-G1, 23520-G1,27630-G13, JA 343667, TD80-201-00, TO 251-6, CU812009, 824753, 832498, YA93306-20304, 93306-20309,93306-20310, 93306-20314,93306-20316, 93306-20324,93306-20331, 93306-20345,903306-203X1,J56-H1857-00-00, HYGB1-801003Item Description -Front Inner Wheel Bearing for1983 and newer HarleyDavidson, also both sides ofBalancer Shaft on 1995 andnewer 4 cycle, Club Car gasbalancer shaft clutch side,camshaft flywheel from 1984 to1991 and electric motor brushend from 1981 and newer(except IQ system), E-Z-GOelectric motor brush end on1980 to 1996, also Jacobsen,Taylor Dunn, Toro, Cushman,also Yamaha front outer wheelbearing for G1 from 1978 to1981 and electric motor brushend on 1990 and newer G8, G9,G14, G16, G19 and G20, AlsoHyundai. Dimensions: .66"(16.8mm) I.D. by 1.57"(39.9mm) O.D. by .47"(11.9mm) W.

High Speed 10 SplineMotorPrice: $599.45Part Number: MT406OEM Part Numbers - CC1012643, 1012653, 1014678,1017728-02, 1018134-01,1018134-02, 1022374-01, YAJG6-H1890-00, JG6-H1890-01,GE 5BC49JB3071Item Description -10 Spine High Speed Motor for1984 and newer Club Car andYamaha 1989 to 1993-1/2 G1,G2, G8, and G9 with Grazianoor Kawasaki Differentials, 4horsepower at 36 Volts and4150 RPMs, 5.5 horsepower at48 Volts and 5700 RPMs, willreplace above OEM Club Carpart numbers, This motor worksbest at 48 volts having a goodcombination of torque andspeed. At 48 volts it will do 25mph. NOTE: at 48 Volts you willneed a 400 amp or largercontroller. It is also highlyrecommended to run heavy dutycables and a heavy duty forwardand reverse switch our partnumber FR410. NOTE: Not foruse with Club Car PowerDrivePlus systems. Will do speeds upto 25 MPH.

High Speed 36 VoltMotorPrice: $574.49Part Number: MT407OEM Part Numbers - CC1012643, 1012653, 1014678,1017728-02, 1018134-01,1018134-02, 1022374-01, YAJG6-H1890-00, JG6-H1890-01Item Description -10 Spine 36 Volt High SpeedMotor for 1984 and newer Club

Motor InsulatingBushing KitPrice: $11.31Part Number: MT117OEM Part Numbers -HD82837-86, CC 1011407, CU824711, EZ 15437-G1, DA56232, LE 2227-37, NO M-4Item Description -G.E. Motor Insulating BushingKit for G.E. Motor with SquareInsulating Bushing which is



Car and Yamaha 1989 to1993-1/2 G1, G2, G8, and G9with Graziano or KawasakiDifferentials. 6.1 HP @ 4600RPMs. Speeds up to 25 MPHon 36 volts. NOTE: Must use400 amp or higher controller.NOTE: Not for use with ClubCar PowerDrive Plus systems.NOTE will replace OEM partnumbers above. Important Note:This low torque high speedmotor is not suitable for liftedcarts. Also best used wherethere art not a lot of hills

.227" thick with .335" hole forold style GE Motors used onHarley Davidson, 1984 to 1993Club Car, Cushman, E-Z-GO,Davis, Noland, and others,Includes the plastic squarebushing, two fiber washers, onewith a .330" hole and the otherwith a .475" hole plus one 5/16"steel washer and one 5/16"serrated nut.

Brush Holder withSpringsPrice: $87.79Part Number: BR116OEM Part Numbers - HD82916-79, 82919-79, CC1011326, 1011420, YAJ14-81813-10Item Description -Brush Holder with Springs forlate 1979 to 1982 HarleyDavidson model DE3 and MGIVwith Hitachi Motor only, alsoClub Car 1980 to 1984, andYamaha G1 and G2.

High Torque MotorPrice: $697.95Part Number: MT410OEM Part Numbers - GE5BC48JB1134Item Description -Very High Torque 10 Spine 36and 48 Volt Motor for 1984 andnewer Club Car and 1989 to1993-1/2 Yamaha G1, G2, G8,and G9 with Graziano orKawasaki Differentials. 8 HP @1600 RPMs at 36 volts and 11HP @ 2300 RPMs at 48 volts.NOTE: This is a very hightorque motor recommended forhilly areas and lifted carts eithlarger tires. Speeds up to 15MPH on 36 volts and 18 MPHon 48 volts with stock tires.Larger tires will increase speed.NOTE: Must use 400 amp orhigher controller and upgrade to4 gauge wires. NOTE: Not foruse with Club Car PowerDrivePlus systems.

BR206Price: $60.45Part Number: BR206OEM Part Numbers - EZ16917-G1, 27630-G05, CC1011282, 1011410, HD83283-86, CU 886026, TD70-104-00, ND 20953, LE5561-2, HY GB1-801062Item Description -Brush Set with Stud for EarlyStyle G.E. Motor for 1980 to1992 E-Z-GO, 1980 to 1993Club Car, Harley, Cushman,Taylor Dunn,Nordskog/Marketeer, Legend,and Hyundai. Dimensions:

Give us a call!1 (360) 385-4868





1-7/16" long by 5/8" wide by 1/2"thick



REAR AXLES & DIFFERENTIALBearing, Crankshaft &Rear AxlePrice: $15.12Part Number: BE111

OEM Part Numbers - CO83032-96, CC 7336, 1011291,1011317, 1012677, 1012685,1012726, 1013777, 1013793,EZ 26783-G01, 26811-G01,51051-G1, 73120-G07, TD80-504-00, CU 815093, 821292,823012, 823292, 824669,824704, 826681, 832412,832499, 835016, YA93306-20504, 93306-20509,93306-2050X, 93306-2013,93306-20517, 93306-20519,90336-20525, 93306-20529,93306-20541, NO T-28, NDA413A986H07, PA 1538Item Description -Crankshaft Bearing for 1982 to1995 Harley Davidson 2 cycleengine, fan side, also 1996 to2000 rear axle, Club Car DSrear axle 1984 to 1986 with Fujirear axle, E-Z-GO 2 cycle gascrankcase flywheel side, 1976to 1979 and 4 cycle gas inputshaft clutch side for 1994 andnewer and rear axle for 1991and newer, Yamaha rear axle1978 to 1994 G1, G2, G8, G9and 4 cycle gas input shaft from1985 to 1995 G2, G8, G9 andelectric input shaft from 1981 to1992 G1, G2, G8, G9, Cushmandifferential, also Noland,Nordskog, Pargo and TaylorDunn, .980" (24.9mm) I.D. by2.050" (51.9mm) O.D. by .590(14.9mm) wide


OEM Part Numbers -CU835013, EZ 23519-G1, NOT-19, PA 2632, 3153, YA93306-00511, 93306-0513,93306-00518, 93306-00541,93306-00543, 93306-005Y1,93306-005Y3Item Description -Outer Rear Axle Bearing for1976 to 1984 Club Car, also fitsthe following with TerrillDifferentials, early rear axle onE-Z-GO, Cushman, Pargo,Noland, also Yamaha inputshaft bearing on 1993 andnewer electric G9 and G14,G16, G20, G21, G22, alsoYamaha front inner wheelbearing on 1982 to 2002 G1,G2, G8, G9, G14, G16, G19,G20, G21 and 2003 electricfront outer wheel bearing Note:Not available from Club Carseparately, .980" (25mm) I.D. by1.850" (47mm) O.D. by .470"(11.9mm) wide

Rear Axle SealPrice: $4.29Part Number: BE401

OEM Part Numbers - CC 7906,EZ 2633, CU 835022, LE 2633,NO T-38, PA 2633Item Description -Outer Rear Axle Seal for 1976to 1984 Club Car with Terrellrear differential, also earlyE-Z-GO, Cushman, Legend,Noland, Pargo with Terrell

Intermediate PinionBearingPrice: $8.19Part Number: BE707OEM Part Numbers - PA 3162,CC 7335, EZ 26785-G1, HD9038, CU 835011, NO T-18, YA93303-20421, HYItem Description -Intermediate Pinion ShaftBearing Bearing, non sealed,open sided for 1965 to 1975Pargo with Terrill differential,

CLUB CAR REAR AXLES & DIFFERENTIAL

CLUB CAR REAR AXLES & DIFFERENTIAL 56

Differential, Dimensions: 1.12"(28.6mm) I.D. by 1.84"(46.8mm) O.D. by .30" (7.7mm)wide, not available separatelyfrom Club Car

Club Car located on oppositemotor input on 16 splinedifferentials and both sides ofthe pinion on some differentialswith taper shaft motors, E-Z-GOon 1991 and newer differentials,Harley, Cushman input shaft,also Noland and Hyundaidifferentials, Yamaha 1992 andolder electric G1, G2, G8, G9,7/8" I.D. bearing

Intermediate PinionBearingPrice: $9.36Part Number: BE706OEM Part Numbers - PA 1538,CC 7330, EZ 26783-G01, YA93306-20529, HD 9032, CU815093, NO T-28Item Description -Intermediate Pinion ShaftBearing Bearing for 1969 to1975 Pargo with Terrilldifferential with 16 spline motor,also Club Car 1984 and newerfront opposite motor sideintermediate pinion shaftbearing, E-Z-GO 1991 andnewer 4 cycle gasdifferential,Yamaha 1992 andolder electric G1, G2, G8 outershaft or carrier on both sides,also Harley, Cushman, andNoland

Carrier Gear BearingPrice: $18.54Part Number: BE704OEM Part Numbers - PA 3155,CC 7330, 1013778, EZ26806-G01, YA 93306-00803,NO T-18Item Description -Open Sided Carrier GearBearing for Pargo 1965 to 1975with Terrill differential, also ClubCar 1976 to 1984 with Terrilldifferential, and 1984 and newerDS and Precedent with eitherKawasaki or Graziano reardifferentials, E-Z-GO 1991 andnewer 4 cycle gas, Yamaha1992 and older G1, G2, G8 andNolan. Dimensions: 1.57"(39.9mm) I.D. by 2.68"(68.1mm) O.D. by .58"(14.9mm) W.

Pinion BearingPrice: $12.87Part Number: BE705OEM Part Numbers - PA 3364,CC 7333, CU 835020, LE 3162,NO T-32Item Description -Motor Input Pinion Bearing for1969 to 1975 Pargo andCushman with Terrill differentialwith 16 spline motor, also ClubCar 1984 to 1986 motor sideintermediate gear with Fujidifferential, also Legend andNoland. Open on both sideswith snap ring, Dimensions:1.17" (29.8mm) I.D. by 2.16"(54.9mm) O.D. by .51"(12.9mm) W.

Lug NutPrice: $0.69Part Number: WH129OEM Part Numbers -CC1010984, HD 43152-66, CU800573, EZ 14723-GI, TD97-236-00, JA 555977Item Description -Steel Lug Nut for 1974 andnewer Club Car, Harley,Cushman, E-Z-GO all years,Taylor Dunn, Jacobsen, andothers, NOTE: 1/2" by 20threads, right hand.



Differential GasketPrice: $3.32Part Number: AX405OEM Part Numbers -CC 7346,CU 835008, EZ 3148, LE 3152,NO T-14, PA 3048Item Description -Differential Case Gasket forClub Car 1980 to 1984,Cushman, E-Z-GO, Legend,Noland, and Pargo, all withTerrell Differential

Rear Axle BearingPrice: $11.02Part Number: BE405OEM Part Numbers - CC1011291, CU 832499, TD80-207-00, ND 20013, PA 3055,HD 72380-72Item Description -Outer Rear Axle Bearing for1984 and newer Club Carmodels DS and Precedent,Cushman rear axle, TaylorDunn rear axle, Nordskog rearaxle, Pargo rear axle, andHarley motor com end bearingwith GE motor

Rear Axle BearingPrice: $11.61Part Number: BE406OEM Part Numbers - CC1012685, CO 83036-96, EZ26811-G01, TD 80-504-00Item Description -Inner Rear Axle Bearing for1984 to 1986 Club Car with Fujirear axle, 1996 and newerColumbia Harley rear axle, 1991and newer 4 cycle E-Z-GO rearaxle, and Taylor Dunntransmission bearing.

Axle BushingPrice: $22.23Part Number: BE407OEM Part Numbers - 1014207Item Description -Axle Bushing for 1985 andnewer Club Car models DS andPrecedent with Kawasaki "K"transaxle

Rear Axle SealPrice: $6.15Part Number: BE408OEM Part Numbers - 1012683Item Description -Rear Axle Seal for 1984 to 1985Club Car with Fuji transaxle

Rear Axle SealPrice: $4.49Part Number: BE409OEM Part Numbers - 1013794Item Description -Rear Axle Seal for 1986 andnewer Club Car models DS andPrecedent

Rear AxlePrice: $246.23Part Number: AX400OEM Part Numbers -1013785Item Description -Right Rear Axle for 1985 to1996 Club Car Electric modelDS and 1986 to 1996 Gas withKawasaki rear differential, withsplines, NOTE: Includes bearingand retainer

Rear AxlePrice: $246.23Part Number: AX401OEM Part Numbers -1013786Item Description -Left Rear Axle for 1985 to 1996Club Car Electric model DS and1986 to 1996 Gas withKawasaki rear differential, withsplines, NOTE: Includes bearingand retainer



SOLENOIDS36 Volt SolenoidPrice: $31.20Part Number: SO400OEM Part Numbers -CC 8016,NO 801-6Item Description -36 Volt 4 Terminal Solenoid for1978 to 1998 Club Car, alsoNolan

12 Volt SolenoidPrice: $30.74Part Number: SO402OEM Part Numbers -1012275,1013609Item Description -12 Volt Starter Solenoid for1984 and newer Club Car modelDS and Precedent gas carts

Bus BarPrice: $4.75Part Number: SP406OEM Part Numbers -8543Item Description -Copper Bus Bar for Solenoidsfor 1981 to 1988 Club Car, fivedrilled holes to connect fivesolenoids, 11-1/2 inches long

Bus BarPrice: $4.75Part Number: SP405OEM Part Numbers -8309Item Description -Copper Bus Bar for Solenoidsfor 1974 to 1980 Club Car, fivedrilled holes to connect fivesolenoids, 10 inches long

36 Volt SolenoidPrice: $19.95Part Number: SO407OEM Part Numbers-1019759-01Item Description -36 Volt Solenoid for 1988 andnewer Club Car electric modelDS, has silver contacts and fourterminals

48 Volt SolenoidPrice: $76.05Part Number: SO408OEM Part Numbers - CC1018836-01, WR586-120111-2B1, 586-120111,586-120111-B1,586-120111-5B1Item Description -48 Volt 4 Trminal Solenoid for1998 and newer Club Car,E-Z-GO and Columbia Harleywith 48 Volt systems, alsoYamaha 1995 and newerelectric G19, G22, has silvercontacts, 200 amp rating

DiodePrice: $3.32Part Number: SP106OEM Part Numbers -21762-G1,74886-67, 30353-G8Item Description -Columbia/Harley-Davidson withelectric controller. 1990 to 1999.3 Amp diode (for solenoid).OEM Quality.

36 Volt SolenoidPrice: $78.21Part Number: SO105OEM Part Numbers - HD71458-87, EZ 20468-G1, CC1016072, YA JF3-H1950-00,ME 510204, TD 72-501-38, JA556294 WR 586-117111,586-117111-2B1,586-117111-5B1Item Description -36 Volt, 4 Terminal, Heavy DutySolenoid for 1987 and newerColumbia Harley Davidson,E-Z-GO electric 1989 andnewer, Club Car electricindustrial vehicles 1988 andnewer, Yamaha electric 1990and newer G8, G9, G11, G14,G16, Melex 1986 and newerwith electronic speed control,

CLUB CAR SOLENOIDS

CLUB CAR SOLENOIDS 59

also Taylor Dun, Jacobsen, Hassilver contacts rated for 200amps continuous or 600 ampspeak. NOTE: Recommended tobe used as a replacementsolenoid when upgrading to ahigher amp controller and canbe used as a replacement inmany other applications wherehigh current capability isrequired.

Resistor for SolenoidPrice: $4.35Part Number: SO210OEM Part Numbers - EZ21764-G1, CC 1014947, CO70592-87Item Description -Resistor that goes across largeposts on 1989 and newerE-Z-GO with electronic solidstate speed controller. Not foruse with 1995 to 1999 DCS(Drive Control System)carts.Also for 1990 and newer ClubCar, Columbia Par Car/Harley,and Cushman with Curtis solidstate speed control and 1989and newer Yamaha with Curtissolid state speed control. Alsoused when converting olderresistor carts to modern motorspeed control systems, 250 ohmwith two crimp terminal ends,OEM Quality

Give us a call!1 (360) 385-4868



CLUB CAR SOLENOIDS

CLUB CAR SOLENOIDS 60

SPEED CONTROLBus BarPrice: $4.75Part Number: SP405OEM Part Numbers -8309Item Description -Copper Bus Bar for Solenoidsfor 1974 to 1980 Club Car, fivedrilled holes to connect fivesolenoids, 10 inches long

ResistorPrice: $15.31Part Number: SP400OEM Part Numbers -1010215Item Description -First Speed Resistor for 1976 to1987 Club Car, ten turns of 9gauge wire

ResistorPrice: $15.00Part Number: SP401OEM Part Numbers -1010216Item Description -Second Speed Resistor for1976 to 1987 Club Car, Sixturns of 7 gauge wire

ResistorPrice: $16.58Part Number: SP402OEM Part Numbers -1010217Item Description -Third Speed Resistor for 1976to 1987 Club Car, four turns of 7gauge wire

Resistor MountingBracketPrice: $3.35Part Number: SP403OEM Part Numbers -8541Item Description -Resistor Mounting Bracket for1976 to 1987 Club Car

Resistor BoardPrice: $12.97Part Number: SP404OEM Part Numbers -7241Item Description -Pre Drilled Resistor MountingBoard for 1975 and older ClubCar, Dimensions: 2-1/4" wide by7-3/4" long by 3/16" thick

Bus BarPrice: $4.75Part Number: SP406OEM Part Numbers -8543Item Description -Copper Bus Bar for Solenoidsfor 1981 to 1988 Club Car, fivedrilled holes to connect fivesolenoids, 11-1/2 inches long


Micro SwitchPrice: $3.12Part Number: SW401OEM Part Numbers -1014806,1014808Item Description -Two Terminal Micro Switch forAccelerator Speed Switch on

Motor Speed ControllerPrice: $295.20Part Number: SP130OEM Part Numbers - HD74883-87, EZ 20972, CC1014749, ME 510154,1204-001, 1204-012Item Description -

CLUB CAR SPEED CONTROL

CLUB CAR SPEED CONTROL 61

1981 to 1984 Club Car and gascomponent box on 1984 andnewer as well as the Forwardand Reverse Switch ongasloline Club Cars from 1984to 1998

24 to 48 Volt, 300 AmpElectronic Motor SpeedController, will replace Curtismodel 1204 275 Amp Controlleron 1987 and newerHarley/Columbia Par Par, 1989to 1994 E-Z-GO, 1990 to 1995Club Car, 1986 & newer Melex,and can be used to upgradeother carts from resistor control,uses 0 to 5 k/ohm throttle input,use part number SP140potentiometer throttle whenconverting an older cart, if youare converting a 1983 to 1994E-Z-GO then use potentiometerboard number SP230. Note:equipped with high pedaldisable, this safety feature willnot let the cart start with throttledepressed

DiodePrice: $3.32Part Number: SP106OEM Part Numbers -21762-G1,74886-67, 30353-G8Item Description -Columbia/Harley-Davidson withelectric controller. 1990 to 1999.3 Amp diode (for solenoid).OEM Quality.

Motor Speed ControllerPrice: $354.60Part Number: SP131OEM Part Numbers - HD74883-87, HD 74891-96, EZ20972, EZ 73055-G02 CC1014749, CU 831722, CU832858, ME 510154, 1204-001,1204-012Item Description -24 to 48 Volt, 400 AmpElectronic Motor SpeedController Upgrade, will replaceCurtis model 1204 275 AmpController on 1987 and newerHarley/Columbia Par Par, 1989to 1994 E-Z-GO, 1990 to 1995Club Car, 1986 & newer Melex,and can be used to upgradeother carts from resistor control,uses 0 to 5 k/ohm throttle input,use part number SP140potentiometer throttle whenconverting an older cart, if youare converting a 1983 to 1994E-Z-GO then use potentiometerboard number SP230. Note:equipped with high pedaldisable, this safety feature willnot let the cart start with throttledepressed

Pot BoxPrice: $129.60Part Number: SP140OEM Part Numbers -Item Description -PB-6 Style Potentiometer (Pot

Speed Switch SlidePrice: $8.89Part Number: SP417OEM Part Numbers -1010895,1012798Item Description -



Box), E-Z-GO 1994 and newer,also for use with motor speedcontrollers using 0 to 5 k/ohmthrottle input, use whenupgrading a cart from resistorcontrol to a modern electronicmotor speed controller

Speed Switch Slide for 1980 to1988 pre V Glide ClubCar,injection molded plasticramp that operates microswitches inside retangularspeed switch assembly, fits fromserial number A8036-15260 toA8845-160171ar

Speed Switch AssemblyPrice: $179.40Part Number: SP418OEM Part Numbers -1013410Item Description -Complete Speed SwitchAssembly for 1980 to 1988 ClubCar, inside retangular aluminumhousing are five micro switchesoperated by plastic ramp,includes ball stud connector

V Glide Switch CasePrice: $67.47Part Number: SP419OEM Part Numbers -1014999Item Description -V Glide Switch Case for 1988and newer 36 Volt Club Carmodel DS, black plastic housingwith eight copper contacts andone brass pivot bushing

V Glide Switch Assy.Price: $132.02Part Number: SP420OEM Part Numbers -1016140Item Description -Complete V Glide SwitchAssembly for 1988 and newer36 Volt Club Car model DS

V Glide Wiper Arm &CarrierPrice: $4.35Part Number: SP422OEM Part Numbers -1013887Item Description -Wiper Arm for V-Glide SpeedSwitch on 1988 and newer 36Volt Club Car model DS

V Glide Switch CoverPrice: $6.45Part Number: SP421OEM Part Numbers -1013886Item Description -V Glide Black Plastic SwitchCover for 1988 and newer 36Volt Club Car model DS

36 to 48 Volt SpeedControllerPrice: $579.75Part Number: SP430OEM Part Numbers -CC1018402-01, Curtis 1204-413,will replace 1204-410Item Description -36 to 48 Volt, 275 Amp MotorSpeed Controller for 1996 andnewer Club Car model DS withPowerdrive system with serieswound motor. Takes 5K to 0ohms throttle input.

Resistor for SolenoidPrice: $4.35Part Number: SO210OEM Part Numbers - EZ21764-G1, CC 1014947, CO70592-87Item Description -Resistor that goes across largeposts on 1989 and newerE-Z-GO with electronic solidstate speed controller. Not foruse with 1995 to 1999 DCS(Drive Control System)carts.Also for 1990 and newer Club

36 Volt SolenoidPrice: $78.21Part Number: SO105OEM Part Numbers - HD71458-87, EZ 20468-G1, CC1016072, YA JF3-H1950-00,ME 510204, TD 72-501-38, JA556294 WR 586-117111,586-117111-2B1,586-117111-5B1Item Description -36 Volt, 4 Terminal, Heavy DutySolenoid for 1987 and newerColumbia Harley Davidson,



Car, Columbia Par Car/Harley,and Cushman with Curtis solidstate speed control and 1989and newer Yamaha with Curtissolid state speed control. Alsoused when converting olderresistor carts to modern motorspeed control systems, 250 ohmwith two crimp terminal ends,OEM Quality

E-Z-GO electric 1989 andnewer, Club Car electricindustrial vehicles 1988 andnewer, Yamaha electric 1990and newer G8, G9, G11, G14,G16, Melex 1986 and newerwith electronic speed control,also Taylor Dun, Jacobsen, Hassilver contacts rated for 200amps continuous or 600 ampspeak. NOTE: Recommended tobe used as a replacementsolenoid when upgrading to ahigher amp controller and canbe used as a replacement inmany other applications wherehigh current capability isrequired.

Resistor Mounting BoardPrice: $29.54Part Number: SP407OEM Part Numbers -1014728Item Description -Pre Drilled Resistor MountingBoard for 1976 to 2000 ClubCar model DS carts,Dimensions: 2" wide by 11-3/8"long by 3/16" thick

Wiper arm HolderPrice: $10.85Part Number: SP423OEM Part Numbers -1014017Item Description -Wiper Arm Holder for V-GlideSpeed Switch on 1988 andnewer 36 Volt Club Car modelDS

Wiper Arm & CarrierPrice: $14.45Part Number: SP424OEM Part Numbers -1013887,1014017Item Description -Wiper Arm and Holder forV-Glide Speed Switch on 1988and newer 36 Volt Club Carmodel DS

Wiper BrushPrice: $15.60Part Number: SP425OEM Part Numbers -1013887Item Description -Wiper Arm Brush for V-GlideSpeed Switch on 1988 andnewer 36 Volt Club Car modelDS



STEERING & SUSPENSIONTie Rod EndPrice: $14.93Part Number: ST433OEM Part Numbers -7539Item Description -Tie Rod End for 1976 andnewer Club Car, right handthread

Tie Rod EndPrice: $14.93Part Number: ST434OEM Part Numbers -7540Item Description -Tie Rod End for 1976 andnewer Club Car, left handthread

Front HubPrice: $32.66Part Number: ST425OEM Part Numbers -7114,1011102, 1011153, 1011889,1011892, 1011894Item Description -Aluminum Front Wheel Hub for1974 to 2003 Club Car modelDS carts up to serial numberAQ0344-343603 and on theelectric models up to serialnumber AQ0343-342005 on thegas models. Also works on IQcarts up to 2004.

SealPrice: $10.98Part Number: BE402

OEM Part Numbers - PA2227-33, JA 325472Item Description -Front Wheel Hub Seal for 1975and earlier Club Car, also motorseal on Pargo and Jacobsen.Dimensions: 1.381" O.D. by.812" I.D. by .254" width

Rear ShockPrice: $36.49Part Number: ST403

OEM Part Numbers - 1012183,1013164, 1014236Item Description -Rear Shock Absorber for 1988and newer Club Car electricmodels DS and Precedent.Uses shock mounting bushingkit number ST218 not included,Measurements: compressedlength: 11-1/2", Extendedlength: 14-1/2"

Grease CapPrice: $3.95Part Number: ST429OEM Part Numbers -7275Item Description -Front Wheel Hub Grease Capfor 1974 to 1981 Club Car


Leaf Spring Bushing KitPrice: $4.35Part Number: ST422OEM Part Numbers -7050,7051, 1010160, 1011416,1012303, 1015583Item Description -Leaf Spring Bushing Kit for ClubCar, fits Front Spring of 1976and newer gas and electric andRear Springs on 1981 andnewer gas and electric DSmodels, NOTE: two kits requiredper spring

CLUB CAR STEERING & SUSPENSION

CLUB CAR STEERING & SUSPENSION 65

Wheel Bearing SetPrice: $9.47Part Number: BE106OEM Part Numbers - HD 9033,CC 7274, 7308 1011393, EZ11750-G1, 11752-G1,50908-G1, 1720008, 3523903,CU 385174, 548124, 548127,808088, 808089, LE 3-3339,ME 300339, ND 10357, TD80-015-00, 80-105-00, JA354735, 500534, 546638,546639, 593793, PA 3045, 3046Item Description -Front Wheel Bearing Set for1963 to 1987 Harley-Davidson 3Wheel, 1974 to 2003 Club Carfront wheel on DS 4 wheel carts,E-Z-GO 3 wheel 1967 andnewer, Cushman front wheel allcarts, Legend, Melex, Nordskog,also Westinghouse model 436,437, 438, 439, and model 139front wheel, Taylor Dunn,Jacobsen, Toro, Otis and Pargo3 wheel. Dimensions: .74"(18.7mm) I.D. by 1.8" (45.2mm)O.D. by .47" (12mm) W., innerrace width .66"


OEM Part Numbers - 1013135Item Description -Front Wheel Seal for 1982 andnewer gas and electric ClubCar, 1.940" (49.4mm) O.D. by1.070" (27.1mm) I.D. by .460"(11.8mm) wide


OEM Part Numbers - CC 7273,CU 807630, LE 3-3334Item Description -Front Wheel Bearing Seal for1976 to 1981 Club Car,Cushman, Legend, 1.100"(27.9mm) I.D. by 1.780"(45.3mm) O.D. by .460"(11.8mm) wide

Steering Bearing SetPrice: $27.59Part Number: BE103

OEM Part Numbers - HD57082-67, CC 1011401, EZ5574, 5575, CU 818902, TD18-307-53, 18-307-56,18-307-57, DA 40903, OTA-40903, PA 3082Item Description -Worm Shaft Bearing and RaceSet for Steering Box onHarley-Davidson 3 and 4 Wheel,Club Car 1976 to 1983, E-Z-GO,Cushman, Taylor Dunn, Davis,Otis, and Pargo. Dimensions ofRace: .88" (22.2mm) I.D. by1.53" (38.8mm) O.D. by .27"(6.9mm) W.

Wheel Hub KitPrice: $49.74Part Number: ST426OEM Part Numbers - 1011892Item Description -Front Wheel Hub Kit for 1982 to2003 Club Car, includes fronthub, bearings and races, lugbolts and nuts, seal and dust

Rear Leaf SpringPrice: $48.76Part Number: ST410OEM Part Numbers -1010974Item Description -Rear Leaf Spring for 1981 andnewer electric Club Car modelDS



cap

Rear Leaf SpringPrice: $41.44Part Number: ST411OEM Part Numbers -1012324Item Description -Rear Leaf Spring for 1984 andnewer gas Club Car model DS

Heavy Duty Rear LeafSpringPrice: $60.45Part Number: ST412OEM Part Numbers -1011149,1012618, 1014675Item Description -Heavy Duty Rear Leaf Springfor 1981 and newer gas andelectric Club Car model DS,measures 28-1/8" between eyes

Front Leaf SpringPrice: $34.91Part Number: ST413OEM Part Numbers -1010136,1012030, 1012322, 1013867,1015108, 1015828Item Description -Front Leaf Spring for 1981 andnewer gas and electric Club Carmodel DS, measures 27-/4"between eyes

Heavy Duty Front LeafSpringPrice: $58.50Part Number: ST414OEM Part Numbers -1012324Item Description -Heavy Duty Front Leaf Springfor 1981 and newer gas andelectric Club Car model DS,measures 27" between eyes

Steering BoxPrice: $226.20Part Number: ST437OEM Part Numbers-1018783-02Item Description -Rack and Pinion Steering GearBox for 1984 to 2005 gas andelectric Club Car model DS

Urethane Leaf SpringBushingPrice: $1.75Part Number: ST420OEM Part Numbers -1015583,7050Item Description -Leaf Spring Bushing for 1976and newer gas and electric ClubCar model DS and Precedent,Also Lower A-Plate Bushing for1992 Club Car ONLY

Steel Leaf SpringBushingPrice: $1.45Part Number: ST421OEM Part Numbers -1010160,1012303, 7051Item Description -Steel Leaf Spring Bushing for1976 and newer gas andelectric Club Car model DS

Rear ShockPrice: $29.74Part Number: ST402

OEM Part Numbers -1011085,1011414, 1012781, 1014234Item Description -Rear Shock Absorber for 1984to 1996 Club Car gas modelsDS. Uses shock mountingbushing kit number ST218 notincluded, Measurements:compressed length: ", Extendedlength: "

Shock Bushing KitPrice: $3.95Part Number: ST218

OEM Part Numbers -EZ10194-G1, 10435-G1,13270-G1, 15707-G1,

Steering Tube BushingPrice: $6.34Part Number: ST120OEM Part Numbers -HD 57067,57067-68, CC 7841, EZ 5568,1701337, 31772-G1, 50201-G1,CU 819924, 831135, JA



20278-G1, 20279-G1, CC1010142, 1010144, 1010415,ME 300324, 300325Item Description -Shock Absorber Bushing Kit forall years E-Z-GO, Club Car,Melex also others, includes 2rubber bushings, 2 washers, 2nuts and 2 "pal" locking nuts

546064, ME 300524, NO 280C,ND 12878, OT A-53952, PA3080Item Description -Upper Steering Tube Bushingfor Harley Davidson, gas andelectric, late 1968 model D gasafter serial number 680-10757to 1981 and 1969 to 1981 modelDC and D4, late 1968 to 1981model DE electric after serialnumber 68DE-6172, and 1969to 1970 model DEC, and 1977to 1981 electric model DE3, also1979 to 1982 electric modelMGIV, also fits Club Car 1976 to1984 electric, E-Z-GO 1965 to1970, Cushman, Jacobsen,Melex, Noland, Nordskog, Otis,and Pargo

Steering Tube GasketPrice: $1.55Part Number: ST121OEM Part Numbers -HD570670-68, CC 1012466, EZ16722-G1, CU 819923, DA53756, JA 555102, NO 280D,OT A-53756, PA 1727Item Description -Upper Steering Tube DustCover Gasket for HarleyDavidson, gas and electric, late1968 model D gas after serialnumber 680-10757 to 1981 and1969 to 1981 model DC and D4,late 1968 to 1981 model DEelectric after serial number68DE-6172, and 1969 to 1970model DEC, and 1977 to 1981electric model DE3, also 1979 to1982 electric model MGIV, alsofits Club Car 1976 to 1994,E-Z-GO 1965 to 1970,Cushman, Davis, Jacobsen,Melex, Noland, Nordskog, Otis,and Pargo

Steering WheelPrice: $67.96Part Number: ST107OEM Part Numbers -HD57075-69, CC 8584, EZ16565-G1, CU 888527, TD49-011-20, DA 54089, JA555101, NO 285, OT C-54089Item Description -Replacement Black SteeringWheel for 1963 to 1983 HarleyDavidson, also Club Car 1976 to1984 electric, E-Z-GO 1965 to1982, Cushman, Taylor Dunn,Davis, Jacobsen, Noland, andOtis, NOTE: includes centercap. Measures 14-1/4" diameterwith splined bore diameter of.720".

Steering Wheel CenterCapPrice: $8.39Part Number: ST108OEM Part Numbers -57075-69Item Description -Steering Wheel Center cap forST107 Steering Wheel


OEM Part Numbers -CU835013, EZ 23519-G1, NOT-19, PA 2632, 3153, YA93306-00511, 93306-0513,93306-00518, 93306-00541,93306-00543, 93306-005Y1,93306-005Y3



Item Description -Outer Rear Axle Bearing for1976 to 1984 Club Car, also fitsthe following with TerrillDifferentials, early rear axle onE-Z-GO, Cushman, Pargo,Noland, also Yamaha inputshaft bearing on 1993 andnewer electric G9 and G14,G16, G20, G21, G22, alsoYamaha front inner wheelbearing on 1982 to 2002 G1,G2, G8, G9, G14, G16, G19,G20, G21 and 2003 electricfront outer wheel bearing Note:Not available from Club Carseparately, .980" (25mm) I.D. by1.850" (47mm) O.D. by .470"(11.9mm) wide

Front ShockPrice: $35.25Part Number: ST404

OEM Part Numbers - 1010991,1012284, 1014233, 1014235,1015813Item Description -Front Shock Absorber for 1981and newer Club Car gas andelectric model DS. Uses shockmounting bushing kit numberST218 not included,Measurements: compressedlength: 9-5/8", Extended length:11-3/8"

Front ShockPrice: $48.75Part Number: ST405

OEM Part Numbers -1022885-01Item Description -Front Shock Absorber for 2004and newer Club Car gas andelectric Precedent model, hasrubber bushing mounts on bothends. Measurements:compressed length: 7-5/16",extended length: 10"


OEM Part Numbers -450567Item Description -Front Wheel Seal for pre 1976Club Car, 1-3/8" diameter

A-Plate BushingPrice: $2.05Part Number: ST440OEM Part Numbers -7719Item Description -Inner and Outer A-PlateBushing for 1975 to 1992 ClubCar gas and electric models

Bearing, Crankcase,Axle, Wheel, & MotorPrice: $16.68Part Number: BE126OEM Part Numbers - HD 9030,9034, 72381-72, 83269-79, EZ15488-G1, 51320-G1, CU605636, 808058, 821291,823011, 824703, 835011, YA93306-20401, 93306-20417,93306-20420, 93306-20421,93306-20437, 93306-20469,93306-204X0, J10-81856-10 TD80-200-00, DA 56226, JA

Front Leaf SpringBushingPrice: $3.92Part Number: ST423OEM Part Numbers-1029562-01, 1022874-01Item Description -Urethane Front Leaf SpringBushing for 2004 and newerClub Car Precedent NOTE: tworequired per spring



315947, ND 20383Item Description -Crankcase Bearing for 1963 to1981 Harley Davidson, forclutch and flywheel side, also1983 and newer outer frontwheel bearing on 4 wheelHarley, E-Z-GO motor bearing,Cushman rear axle bearing,Outer Wheel Bearing for 1982 to2002 Yamaha models G1, G2,G8, G9, G14, G16, G20, G21,and electric front wheel innerG22, also Electric Motor Bearingfor brush end on 1978 to 1991models G1 and G2, Also rearaxle bearing on Taylor Dunn,Davis, Jacobsen, and NordskogNOTE: Club Car used thisbearing on the front wheel in2003 on electric carts afterserial number AQ344-343603and on gas carts after serialnumber AG0343-342005.Dimensions: .78" (19.9mm) I.D.by 1.85" (47mm) O.D. by .5"(14mm) wide.

Rear Leaf SpringPrice: $65.35Part Number: ST415OEM Part Numbers-10125093-01Item Description -Rear Leaf Spring for 2004 andnewer electric Club CarPrecedent model

Rear Leaf SpringPrice: $66.33Part Number: ST416OEM Part Numbers-10125130-01Item Description -Rear Leaf Spring for 2004 andnewer gas Club Car Precedentmodel

Front Hub KitPrice: $92.16Part Number: ST427OEM Part Numbers-1023577-01Item Description -Front Hub Kit for 2004 andnewer gas and electric Club CarPrecedent model, Note:Includes inner and puter wheelbearings, Dust Cap and M14 by2 Flanged Spindle Lock Nut

Tie RodPrice: $17.67Part Number: ST435OEM Part Numbers -1010219Item Description -Tie Rod for 1993 and newer gasand electric Club Car DS model.

Tie Rod EndPrice: $36.11Part Number: ST436OEM Part Numbers-1023577-01Item Description -Tie Rod End for 2004 andnewer gas and electric Club CarPrecedent model, right hand

Grease CapPrice: $2.45Part Number: ST430OEM Part Numbers -1011887Item Description -Front Wheel Hub Grease Capfor 1982 to 2002 Club Carmodel DS carts



threads.

Grease CapPrice: $2.95Part Number: ST431OEM Part Numbers-1023532-01Item Description -Front Wheel Hub Grease Capfor 2003 and newer Club CarDS models

A-plate Sub AssemblyPrice: $37.45Part Number: ST441OEM Part Numbers -1011002,1014713, 1015586Item Description -Right Passenger Side A-PlateSub Assembly for 1980 to 1992Club Car gas and electric modelDS, includes bushings

A-Plate Sub AssemblyPrice: $37.45Part Number: ST442OEM Part Numbers -1011001,1014712, 1015589Item Description -Left Driver Side A-Plate SubAssembly for 1980 to 1992 ClubCar gas and electric model DS,includes bushings

Short Shoulder BoltPrice: $2.15Part Number: ST443OEM Part Numbers -1010125Item Description -Short Shoulder Bolt for A-PlateSub Assembly on 1979 to 1992Club Car gas and electric modelDS.

Long Shoulder BoltPrice: $3.55Part Number: ST444OEM Part Numbers -1010126Item Description -Long Shoulder Bolt for A-PlateSub Assembly on 1979 to 1992Club Car gas and electric modelDS.

Kin PinPrice: $15.55Part Number: ST445OEM Part Numbers -1010121,1016386Item Description -King Pin for Delta Plate on 1981and newer Club Car gas andelectric model DS.

SpindlePrice: $89.91Part Number: ST446OEM Part Numbers -1010344,1010347, 1011392Item Description -Right Passenger Side FrontSpindle with Bronze Bushingsfor 1981 to 2003 Club Car gasand electric model DS.

SpindlePrice: $91.68Part Number: ST447OEM Part Numbers -1010342,1010348, 1011391Item Description -Left Driver Side Front Spindlewith Bronze Bushings for 1981to 2003 Club Car gas andelectric model DS.

Thrust WasherPrice: $1.85Part Number: ST448OEM Part Numbers - 8068 ,1010150Item Description -Thrust Bearing Washer for KingPin and Spindle Assembly on1981 to 2003 Club Car gas andelectric model DS.

Upper Spindle BushingPrice: $2.75Part Number: ST449OEM Part Numbers -8067Item Description -Upper Bronze Spindle Bushing1979 and newer Club Car gasand electric model DS.



Lower Spindle BushingPrice: $2.65Part Number: ST450OEM Part Numbers -7048Item Description -Lower Bronze Spindle Bushing1979 and newer Club Car gasand electric model DS.

Spindle NutPrice: $1.85Part Number: ST451OEM Part Numbers -7840Item Description -Front Spindle Castle Nut 1974to 2003 Club Car gas andelectric models.

Front Leaf Spring BoltPrice: $2.85Part Number: ST418OEM Part Numbers -1016386Item Description -Front Leaf Spring to King PinBolt for 1981 and newer ClubCar gas and electric model DS.

Leaf Spring NutPrice: $0.82Part Number: ST419OEM Part Numbers -8755Item Description -Nut for Leaf Spring to King PinBolt for 1981 and newer ClubCar gas and electric model DS.

King Pin Wave WasherPrice: $0.65Part Number: ST452OEM Part Numbers -1016389Item Description -King Pin Wave Washer for 1992and newer Club Car gas andelectric model DS.

Delta Shock & GearSupportPrice: $57.64Part Number: ST453OEM Part Numbers -1016385Item Description -Delta Shock and Gear Supportfor 1993 and newer Club Cargas and electric model DS.

A-plate Sub AssemblyPrice: $35.98Part Number: ST454OEM Part Numbers -1016351,1016353Item Description -Delta A-plate Sub Assembly for1993 and newer Club Car gasand electric model DS, for bothsides.

Delta A-plate StrapPrice: $4.35Part Number: ST455OEM Part Numbers -1017266Item Description -Delta A-plate Strap for 1993 andnewer Club Car gas and electricmodel DS.

Delta Upper ClevisPrice: $3.45Part Number: ST456OEM Part Numbers -1016384Item Description -Delta Upper Clevis for 1993 andnewer Club Car gas and electricmodel DS.

Short Delta A-plateBushingPrice: $1.25Part Number: ST457OEM Part Numbers -1016349Item Description -Short Sleeve Bushing for DeltaA-plate on 1993 and newer ClubCar gas and electric model DS.

Long Delta A-plateBushingPrice: $1.55Part Number: ST458OEM Part Numbers -1016350Item Description -Long Sleeve Bushing for DeltaA-plate on 1993 and newer ClubCar gas and electric model DS.

Black A-plate BushingPrice: $1.75Part Number: ST459OEM Part Numbers -1015583Item Description -Black Urethane Bushing forLower A-plate on 1992 onlyClub Car gas and electric modelDS.



Blue Upper & LowerA-plate BushingPrice: $1.25Part Number: ST460OEM Part Numbers -1016346Item Description -Blue Urethane Bushing forUpper and Lower Delta A-plateon 1993 and newer Club Cargas and electric model DS.

Spindle AssemblyPrice: $195.13Part Number: ST461OEM Part Numbers-1028326-01, 1023541-01Item Description -Right Passenger Side Spindlefor 2004 and newer Club Carmodel DS

Spindle AssemblyPrice: $161.85Part Number: ST462OEM Part Numbers -1023541-01Item Description -Left Driver Side Spindle for2004 and newer Club Car modelDS

Control Arm AssemblyPrice: $81.93Part Number: ST463OEM Part Numbers -1022873-01Item Description -Control Arm Assembly for 2004and newer Club Car Precedentmodel, fits both sides

Clevis, Passenger SidePrice: $8.97Part Number: ST464OEM Part Numbers -1022897-01Item Description -Right Passenger Side Clevis for2004 and newer Club CarPrecedent model

Clevis, Driver SidePrice: $9.78Part Number: ST465OEM Part Numbers -1022896-01Item Description -Left Driver Side Clevis for 2004and newer Club Car Precedentmodel

Control Arm Bushing KitPrice: $50.73Part Number: ST466OEM Part Numbers -1022899-01Item Description -Control Arm Bushing andSleeve Kit for 2004 and newerClub Car Precedent model, 6sleeves and 12 bushings

Spindle, Passenger SidePrice: $127.78Part Number: ST467OEM Part Numbers -1022878-01Item Description -Right Passenger Side Spindlefor 2004 and newer Club CarPrecedent model, includesbushing

Spindle, Driver SidePrice: $127.78Part Number: ST468OEM Part Numbers -

King PinPrice: $36.97Part Number: ST469OEM Part Numbers -



1022879-01Item Description -Left Driver Side Spindle for2004 and newer Club CarPrecedent model, includesbushing.

1022872-01Item Description -King Pin for 2004 and newerClub Car Precedent model

Wave WasherPrice: $2.85Part Number: ST470OEM Part Numbers -1022884-01Item Description -King Pin and Spindle WaveWasher for 2004 and newerClub Car Precedent model

Give us a call!1 (360) 385-4868





SWITCHES & CIRCUIT BREAKERSMicro SwitchPrice: $3.45Part Number: SW400OEM Part Numbers -CC1014805, 1014807, 1014887,CU 825217, 829754, 832719,NO 531-82Item Description -Three Terminal Micro Switch forAccelerator Speed Switch on1970 to 1995 Club Car and gascomponent box on 1984 andnewer Club Car as well as theForward and Reverse Switch on1984 and newer gasoline ClubCars, also Cushman Forwardand Reverse Switch as well asFoot Switch Speed Control on36 volt Cushman Titan andMinute Miser, also used onNoland


Micro SwitchPrice: $8.75Part Number: SW202OEM Part Numbers -EZ12374-G1, 13141-G1, CC1011439, OT A-54700Item Description -Plunger Style Micro Switch forLights with three terminals for1971 to 1982 E-Z-GO gas andelectric, Club Car 1981 andnewer with lights, also Otis



Item Description -50 amp Circuit Breaker forLester battery charger on HarleyDavidson, E-Z-GO before TotalCharge, and Club Car, also willreplace 74857-67 diode onHarley Davidson speed controlon master drive control systemon 1969 to 1970 model DEC,1967 to 1971 model DE, and1979 to 1982 model MGIV, tworequired for master drive system.


OEM Part Numbers-1025086-01Item Description -Ignition Switch Only for 2004and newer Club Car ElectricPrecedent model.

IG407Price: $29.25Part Number: IG407

OEM Part Numbers-1018262-01Item Description -Ignition Switch Only for 199 andnewer Club Car 48 Volt modelDS.

CLUB CAR SWITCHES & CIRCUIT BREAKERS

CLUB CAR SWITCHES & CIRCUIT BREAKERS 75


OEM Part Numbers-1018163-01Item Description -Ignition Switch Only for 1996and newer Club Car model DS.


OEM Part Numbers -8204Item Description -Ignition Switch for 1976 to1983-1/2 Club Car, comes with2 keys


OEM Part Numbers -1012531Item Description -Ignition Switch for 1981 to 1995Club Car Electric models,comes with 2 keys


OEM Part Numbers -1012415Item Description -Ignition Switch for 1983-1/2 to1995 Club Car Gas models,comes with 2 keys

CLUB CAR SWITCHES & CIRCUIT BREAKERS

CLUB CAR SWITCHES & CIRCUIT BREAKERS 76

SWITCHES (FORWARD/REVERSE)F & R Switch AssemblyPrice: $45.83Part Number: FR400OEM Part Numbers -1011997,1017530-03Item Description -Forward and Reverse SwitchAssembly for 1983-1/2 to 2001Club Car with 36 volt systemwith resistors, also pre 1983-1/2with modifications, includesmicro switch, does not includehandle, can be retrofitted to beused on earlier Club Cars.NOTE: We now have wiringdiagrams for installing thisswitch on pre 1983-1/2 carts,The link is above the pictures ofthe carts on the Club Car homepage. You will need to drill newmounting holes in the mountingbracket. On 1975 to 1979remove the two motor wires, (A1and A2) that are connected atthe bottom of the switch andjumpered to the rotor. Hookthem back up to the rotor only.Now take (S) wire that wasconnected to the upper right busbar on your old switch and moveit to one of the two lower parallelbus bars. These two bars willneed to be jumpered together.Now take the battery positivecable and hook it to the singlebus bar on the right side. On1981 to 1985 install the twowires that went to the rotor backon the rotor of the new switch.Move battery positive to thesingle right hand bus bar.Connect the S1 terminal fromthe motor to one of the bottomparallel bus bars on the bottomof the new switch. These twobus bars will need to bejumpered together. The fourthwire coming from the middle ofthe battery stack is not used andshould be removed. This wirewas for an 18 volt reverse soyou would not go as fast inreverse

F & R Switch RotorPrice: $6.74Part Number: FR401OEM Part Numbers -7016Item Description -Forward and Reverse SwitchRotor for 1976 to 1983 1/2,houses two FR402 rotorcontacts

Rotor ContactPrice: $7.83Part Number: FR402OEM Part Numbers -

F & R HandlePrice: $8.87Part Number: FR403OEM Part Numbers -1010441

CLUB CAR SWITCHES (FORWARD/REVERSE)

CLUB CAR SWITCHES (FORWARD/REVERSE) 77

Item Description -Rotor Contact for 1976 to 1994Forward and Reverse Switch forClub Car, use with rotor FR401and case FR400

Item Description -Forward and Reverse SwitchHandle for 1970s to 1984 ClubCar


Reverse Warning BuzzerPrice: $13.17Part Number: FR406OEM Part Numbers -1010051Item Description -Reverse Warning Buzzer for1976 to 1991 Club Car electric

F & R HandlePrice: $5.15Part Number: FR404OEM Part Numbers -1012987Item Description -Forward and Reverse SwitchHandle for 1985 and newer ClubCar


F & R Switch RotorPrice: $10.34Part Number: FR405OEM Part Numbers -1011976,1014829, 1016130Item Description -Forward and Reverse SwitchRotor for 1983-1/2 and newer36 volt, houses two FR402 foruse with FR400 case

Give us a call!1 (360) 385-4868



CLUB CAR SWITCHES (FORWARD/REVERSE)

CLUB CAR SWITCHES (FORWARD/REVERSE) 78

WHEELS & TIRESLug BoltPrice: $2.37Part Number: WH260OEM Part Numbers - EZ19682-G1, HD 41199Lug Bolt for Rear Axle or FrontWheel Hub for E-Z-GO, HarleyDavidson and others with .530to .535 hole for serrations and1/2 by 20 threads per inch, boltis 1-1/4 long to shoulder,threads are .960 long, serrateddiameter is .575 by .300 long,has square head

Chrome Lug NutPrice: $2.49Part Number: WH130OEM Part Numbers -Item Description -Chrome Lug Nut, 1/2" by 20threads per inch, fits Harley,Club Car, Cushman, E-Z-GO,Jacobsen, Melex, Nordskog,Pargo, and Taylor Dunn

Wheel/Tire ComboPrice: $122.25Part Number: WH122OEM Part Numbers -Item Description -Golf Pro 205/50-10 Tiremounted on a highly polished10" diameter by 7" wideAluminum Wheel with a 3"offset, 17.5" mounted height ,custom golf cart applications,same height as stock 8 inchwheels

Golf Pro TirePrice: $34.89Part Number: WH100

OEM Part Numbers -Item Description -Sawtooth Tread Tire, size 18 X8.5 X 8, 4 ply rating, for mostmakes and models of golf carts

WheelPrice: $29.74Part Number: WH110

OEM Part Numbers -Item Description -White Steel Wheel, 8" diameterby 7" width with 3" offset, 4holes on 4" bolt circle, fits mostgolf carts

WheelPrice: $29.74Part Number: WH111

OEM Part Numbers -Item Description -Beige Steel Wheel, 8" diameterby 7" width with 3" offset, formost golf carts

Hub Cap Retaining ClipPrice: $0.69Part Number: WH118OEM Part Numbers - 83961-70Item Description -Baby Moon Hub Cap RetainingClip, for use on most metal hubcaps

Wheel/Tire ComboPrice: $56.25Part Number: WH120OEM Part Numbers -Item Description -18X8.50-8 Sawtooth Tiremounted on 8" diameter by 7"wide White Steel Wheel with 3"offset, 4 hole on 4 inch centerbolt pattern, fits most golf carts

Wheel/Tire ComboPrice: $56.25Part Number: WH121

OEM Part Numbers -Item Description -18X8.50-8 Sawtooth Tiremounted on 8" diameter by 7"

Chrome Center CapPrice: $5.73Part Number: WH115OEM Part Numbers -Item Description -Chrome Center Cap for use withpart number WH122. NOTE:2.650" diameter, can be used

CLUB CAR WHEELS & TIRES

CLUB CAR WHEELS & TIRES 79

wide Beige Steel Wheel with 3"offset, 4 hole on 4 inch centerbolt pattern, fits most golf carts

with many stock rims

Inner TubePrice: $19.98Part Number: WH148

OEM Part Numbers -Item Description -Inner Tube size 18 X 8.50/9.50X 8, for most makes and modelsof golf carts

Baby Moon 8''Price: $11.70Part Number: WH113OEM Part Numbers - EZ14913-G1, CC 1034, HD43603-83, CU 887347, YAJG5-F512L-00Item Description -Baby Moon Hub Cap fitsE-Z-GO 1967 and newer, ClubCar 1976 and newer, HarleyDavidson 1963 and newer, ClubCar 1976 and newer, Cushman,and Yamaha, for wheels with7-3/4 inch openings, includesretaining clips number WH118

Tire, Trailer TypePrice: $53.64Part Number: WH205OEM Part Numbers -Item Description -Triler King Tire, 18 X 8.5 X 8, sixply heavy duty, for 8" wheel

Baby Moon 5-3/4''Price: $11.60Part Number: WH114OEM Part Numbers - CU817576, TD 92-001-00Item Description -Baby Moon Hub Cap for ClubCar, Cushman, and Taylor Dunnwith 5-3/4" inch wheel opening,Includes retaining clips partnumber WH118


CLUB CAR WHEELS & TIRES

CLUB CAR WHEELS & TIRES 80

MAIL ORDER FORMVintageGolfCartParts.com -- Mail Order Form

Please follow these instructions:

Print this order form• Complete this form (If you need more space for your item list, please print more copies of this form.)• Return your order form to the following address:

VintageGolfCartParts.com160 Harrison Road, #7Sequim, WA 98382

•

Contact Information

For questions, comments and orders, please contact us using the contact information below:

Email: [email protected]: (360) 385-4868Fax: (360) 582 - 1272 Office Hours: Monday - Friday, 8 AM - 4 PM (PST)

Thank you for visiting VintageGolfCartParts.com

MAIL ORDER FORM MAIL ORDER FORM 81

mailto:[email protected]

Billing Address

Full Name:_________________________________

Address:__________________________________

_________________________________________

City_______________________State___Zip_____

Email:__________________Phone:____________

Shipping Address (Leave blank if same as billing)

Full Name:_________________________________

Address:__________________________________

_________________________________________

City_______________________State___Zip_____

Email:__________________Phone:____________

Item Name / Description Price

# $

# $

# $

# $

# $

# $

# $

# $

# $

# $

# $

# $

# $

Shipping & Handling (please leave blank)

Subtotal (please leave blank)

Payment Method

Please mark (X)Your preferred payment method:

[ ] Personal Check / Money Order [ ] Credit Card

Card Type: [ ] Visa [ ] MasterCard [ ] American Express [ ] Discover

Card Number:_______________________________ Exp:____________(MM/YY)

Name on card:______________________________ Zip Code:______________

MAIL ORDER FORM MAIL ORDER FORM

MAIL ORDER FORM MAIL ORDER FORM 82

CLUB CAR CATALOG - Vintage Golf Cart PartsImportant Notice This PDF catalog represents the products...

Documents

Transcript of CLUB CAR CATALOG - Vintage Golf Cart PartsImportant Notice This PDF catalog represents the products...